马千里,郭春梅,郭式伟,李胜英,陈通,卞晨航
MA Qianli,GUO Chunmei,GUO Shiwei,LI Shengying,CHEN Tong,BIAN Chenhang

• 1:天津城建大学能源与安全工程学院
• 2:天津中怡建筑规划设计有限公司
• 3:天津住宅科学研究院

摘要(Abstract)：

根据天津地区的气象特点,该地区不适宜单独使用直接蒸发冷却空调,因此选用了间接蒸发冷却能量回收新风预冷系统。通过试验研究室内排风对新风的预冷过程,分析了干、湿工况下典型日的运行效果和能效,结果表明:在干工况运行状态下,系统显热节能量较大,没有潜热节能量,COP范围6.47～14.07,能够承担63.28%～144.54%新风冷负荷;湿工况下,发生潜热换热,显著提高总节能量,COP处于13.99～18.11之间,能效较高,新风预冷量占新风冷负荷之比处于44.54%～49.42%。
According to the meteorological characteristics of Tianjin region,it is found that the region is not suitable for using direct evaporative cooling system alone,so fresh air pre-cooling system is selected for the indirect evaporative cooling energy recovery system.The pre-cooling process of the fresh air by indoor exhaust air is studied experimentally,and then the operating effect and energy efficiency of typical days under dry and wet conditions are analyzed.The results show that under dry operating conditions,the sensible heat energy saving of the system is large,and there is no latent heat energy saving,COP is between 6.47 and 14.07,and the system can undertake 63.28%～144.54% fresh air cooling load;latent heat exchange occurs under wet working conditions,which can significantly increase the total energy savings,COP is between 13.99 and 18.11,and the energy efficiency is higher,the proportion of fresh air pre-cooling load to the fresh air cooling load is 44.54%～49.42%.

关键词(KeyWords)： 间接蒸发冷却;能量回收;新风预冷;能效
indirect evaporative cooling;energy recovery;pre-cooling of fresh air;energy efficiency

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金资助项目(51678385);; 天津市科技支撑重点项目(18YFZCSF01390)

作者(Author): 马千里,郭春梅,郭式伟,李胜英,陈通,卞晨航
MA Qianli,GUO Chunmei,GUO Shiwei,LI Shengying,CHEN Tong,BIAN Chenhang

参考文献(References)：

• [1]黄翔.蒸发冷却空调通风系统设计[M].北京：中国建筑工业出版社，2016.HUANG X.Design guide for evaporative ventilation and air conditioning system[M].Beijing：China Architecture & Building Press，2016.
• [2]DUAN Z，ZHAN C，ZHAO X，et al.Experimental study of a counter-flow regenerative evaporative cooler[J].Building & Environment，2016，104：47-58.
• [3]MAHESHWARI G P，AL-RAGOM F，SURI R K.Energy-saving potential of an indirect evaporative cooler[J].Applied Energy，2001，69(1)：69-76.
• [4]HEIDARINEJAD G，BOZORGMEHR M，DELFANI S，et al.Experimental investigation of two-stage indirect/direct evaporative cooling system in various climatic conditions[J].Building and Environment，2009，44:2073-2079.
• [5]DELFANI S，ESMAEELIAN J，PASDARSHAHRI H，et al.Energy saving potential of an indirect evaporative cooler as a pre-cooling unit for mechanical cooling systems in Iran[J].Energy & Buildings，2010，42(11)：2169-2176.
• [6]JIANG Y，XIE X.Theoretical and testing performance of an innovative indirect evaporative chiller[J].Solar Energy，2010，84(12)：2041-2055.
• [7]NAVON R，ARKIN H.Feasibility of direct-indirect evaporative cooling for residences，based on studies with a desert cooler[J].Building & Environment，1994，29(3)：393-399.
• [8]CHEN Y，LUO Y M，YANG H X，A simplied analytical model for indirect evaporative cooling considering condensation from fresh air：Development and application[J].Energy and Buildings 2015，108：387~400.
• [9]李晗，吕建，孟丹东，等.间接蒸发冷却器二次空气的试验研究[J].流体机械，2019，47(3)：75-78.LI H，LYU J，MENG D D，et al.Experimental study on secondary air of indirect evaporative cooler[J].Fluid Machinery，2019，47(3)：75-78.
• [10]李晗，吕建，李勇刚，等.新风风量对间接蒸发冷却器冷凝区域和性能的影响[J].流体机械，2019，47(10)：75-81.LI H，LYU J，LI Y G，et al.The effect of primary air volume flow on condensation area and performance of indirect evaporative cooler[J].Fluid Machinery，2019，47(10)：75-81.
• [11]李晗，吕建，李勇刚，等.风量比对间接蒸发冷却器性能影响的试验研究[J].流体机械，2019，47(7)：56-60.LI H，LYU J，LI Y G，et al.Experimental study on the effect of secondary-to-primary air ratio on the performance of indirect evaporative cooler[J].Fluid Machinery，2019，47(7)：56-60.
• [12]郑斌，郭春梅，吕建，等.新风侧凝结对间接蒸发冷却器换热性能的影响研究[J].流体机械，2018，46(10)：55-62.ZHENG B，GUO C M，LYU J，et al.Research on influence of condensation in fresh air channels on heat transfer performance of indirect evaporative cooler[J].Fluid Machinery，2018，46(10)：55-62.
• [13]张晴原，杨洪兴.建筑用标准气象数据手册[M].北京：中国建筑工业出版社，2012.ZHANG Q Y，YANG H X.Typical meteorological database handbook for buildings[M].Beijin：China Architecture & Building Press，2012.
• [14]黄翔.蒸发冷却空调理论与应用[M].北京：中国建筑工业出版社，2010.HUANG X.Theory and applications of evaporative air conditioning[M].Beijing：China Architecture & Building Press，2010.
• [15]COLEMAN H W，STEELE W G.Experimentation and uncertainty analysis for engineers[M].John Wiley & Sons，New York，1989.