蜗壳喉部面积对离心泵非定常特性的影响Research on the Influence of Volute Throat Area on Unsteady Characteristics in a Centrifugal Pump
陈颖,李国平,张宁,杜文强,高波
CHEN Ying,LI Guo-ping,ZHANG Ning,DU Wen-qiang,GAO Bo
摘要(Abstract):
为研究蜗壳喉部面积对离心泵非定常特性的影响,针对同一离心泵叶轮,设计匹配4种不同喉部面积的蜗壳,并采用数值计算方法对泵内流非定常流动进行计算。结合面积比原理,分析了喉部面积对泵性能、径向力以及压力脉动的影响规律。结果表明:喉部面积对离心泵水力性能影响显著,设计工况下,随着喉部面积的减小,扬程和效率逐渐降低;受喉部面积影响,不同工况叶轮所受径向力大小不同且具有极小值,但极小值所对应的工况点有所不同;合理的喉部面积能有效降低泵内的压力脉动水平,随着喉部面积减小,泵内压力脉动水平增加,而当增加喉部面积时,压力脉动水平降低。通过分析蜗壳不同喉部面积对离心泵性能的影响,可为低噪声离心泵面积比设计提供参考。
For a given impeller,four pumps with different volute throat areas,were calculated based on numerical simulation method.Unsteady flow characteristics of the pumps were obtained.The influences of throat area on hydraulic performance,radial force and pressure pulsation were discussed.Results show that throat area has a great effect on the pump hydraulic performance.The head and hydraulic efficiency decrease with throat area decreasing at nominal flow rate.The radial forces of four impellers differ significantly at various flow rates,which would reach a minimum value.But the corresponding flow rates of the minimum points are different.The reasonable throat area could effectively reduce the amplitude of pressure pulsation,and it would increase with the throat area decreasing.Meanwhile,pressure pulsation energy decreases with the throat area increasing.The obtained results would provide some supports for low noise centrifugal pump design considering different throat areas.
关键词(KeyWords):
离心泵;喉部面积;水力性能;径向力;压力脉动
centrifugal pump;volute throat area;hydraulic performance;radial force;pressure pulsation
基金项目(Foundation):
作者(Author):
陈颖,李国平,张宁,杜文强,高波
CHEN Ying,LI Guo-ping,ZHANG Ning,DU Wen-qiang,GAO Bo
参考文献(References):
- [1]Bo Gao,Ning Zhang,Zhong Li,et al.Influence of the blade trailing edge profile on the performance and unsteady pressure pulsations in a low specific speed centrifugal pump[J].Journal of Fluids Engineering,2016,135(5):051106.
- [2]Ning Zhang,Minguan Yang,Bo Gao,et al.Investigation of rotor-stator interaction and flow unsteadiness in a low specific speed centrifugal pump[J].Journal of Mechanical Engineering,2016,62(1):21-31.
- [3]Parrondo J L,González J,Fernández-Francos.The effect of the operating point on the pressure fluctuations at the blade passage frequency in the volute of a centrifugal pump[J].Journal of Fluids Engineering,2002,124(3):784-790.
- [4]Anderson H H.Mine Pump[J].Journal of Mining Society,1938,6:34-38.
- [5]袁寿其,曹武陵,陈次昌,等.面积比原理和泵的特性[J].农业机械学报,1993,24(2):36-41.
- [6]Worster R C.The flow in volute and its effect on centrifugal pump performance[J].Proc.ⅠMech.E.,1963,177(31):171-174.
- [7]邓文剑,楚武利.叶轮和蜗壳匹配关系对离心泵性能影响的研究[J].石油机械,2008,36(3):9-12.
- [8]刘在伦,梁森,魏清顺.基于面积比原理的水泵设计方法[J].农业机械学报,2007,38(6):196-198.
- [9]Antonio Posa,Antonio Lippolis,Elias Balaras.Large-eddy simulation of a mixed-flow pump at off-design conditions[J].Journal of Fluids Engineering,2015,137:101302.
- [10]Byskov R K,Jacobsen C B,Pedersen N.Flow in a centrifugal pump impeller at design and off-design conditions—part II:Large eddy simulations[J].Journal of Fluids Engineering,2003,125(1):73-83.
- [11]Yang Z J,Wang F J,Zhou P J.Evaluation of subgridscale models in large-eddy simulations of turbulent flow in a centrifugal pump impeller[J].Chinese Journal of Mechanical Engineering,2012,25(5):911-918.
- [12]张金凤,袁寿其,陆伟刚.蜗壳喉部对带分流叶片离心泵功率特性的影响[C].2010国际农业工程大会论文集.
- [13]Wei Jiang,Guojun Li,Peng-fei Liu,et al.Numerical investigation of influence of the clocking effect on the unsteady pressure fluctuations and radial forces in the centrifugal pump with vaned diffuser[J].International Communications in Heat and Mass Transfer,2016,71:164-171.
- [14]高波,王震,杨丽,等.不同口环间隙离心泵性能及水力激励特性分析及实验[J].农业工程学报,2016,32(7):79-85.
- [15]谭蔚,晋文娟,吴皓,等.刚性管对正方形排布管束流体弹性不稳定性的影响研究[J].压力容器,2016,33(3):1-8.
- [16]朱荣生,林鹏,龙云,等.螺旋轴流泵的固液两相流动数值模拟[J].排灌机械工程学报,2014,32(1):6-11.
- [17]王文博,刘厚林,王凯,等.1000 MW级核电站用喷淋泵泵壳安全性分析[J].排灌机械工程学报,2015,33(5):402-406.
- [18]Christopher E Brennen,Allan J Acosta.Fluid-induced rotor dynamic forces and instabilities[J].Structural Control Health Monitoring,2006,13:10-26.