丰兰,康勇,安春燕
FENG Lan,KANG Yong,An Chun-yan(Tianjin University

• 1:天津大学
• 2:天津大学
• 3:天津大学 天津300072
• 4:天津300072

摘要(Abstract)：

针对含油污水设计制作了一套内置新型改性纤维填料的立式油水分离器;考察了该油水分离器进口流速和污水含油浓度对处理后出水油含量和除油效率的影响,并分析了污水含油浓度对油滴脱除粒径的影响。研究结果表明,进口流速小于2L/min时,出水含油浓度随之缓慢增加,且除油效率均在90%以上;当进口流量设定在1.54L/min,进口浓度在从25~1200mg/L内变化时,经过两级处理后油含量最低可以达到4.6mg/L。纤维填料对油滴粒径大于10μm的脱除效率达到了96%以上。
A vertical oil water separator,filled with a newly surface nature changed fiber,was designed to treat oily wastewater.On the basic,the influence of fluid velocity and influent concentration on effluent concentration and efficiency of oil removal began to be measured,the influence of the oil concentration to the removal of the diameter of the oil drop in wastewater was analyzed.The experiment shows,the increase of the effluent concentration was slow when the fluid velocity of inlet varied from 0L/min to 2L/min,and the efficiency of oil removal would be more than 90%;the effluent concentration could reach to 4.6mg/L.when the influent concentration varied from 25mg/L to 1200mg/L and the fluid velocity of inlet was set at 1.54L/min;and the removal percentage of the diameter of the oil drop that small than10μm was more than 96%.

关键词(KeyWords)： 油水分离器;纤维滤床;含油污水
oil water separator;fibrous filter media;oily wastewater

Abstract:

Keywords:

基金项目(Foundation):

作者(Author): 丰兰,康勇,安春燕
FENG Lan,KANG Yong,An Chun-yan(Tianjin University

参考文献(References)：

• [1]Jingquan Li,Yongan Gu.Coalescence of oil-in-wateremulsions in fibrous and granular beds[J].Separationand Purification Technology,2005,42:1-13.
• [2]Radmila M,S ecerov Sokolovic,Tatjana J Vulic.Effect of flow orientation on the coalescence of oildroplets in steady-state bed coalescers[J].Ind.Eng.Chem.Res,2006,45:3891-3895.
• [3]国家环保局《水和废水监测分析方法》编委会编.水和废水监测分析方法[M].第三版.北京:中国环境科学出版社,1989.
• [4]刘成波,李发生,桑义敏,等.含油废水粗粒化处理过程中除油率和油珠粒径分散度的研究[J].石油化工环境保护,2003,26(2):24-27.
• [5]Radmila M.S,ecerov Sokolovic,Slobodan M.Sokolovic.Effect of Working Conditions on Bed Coa-lescence of an Oil-in-Water Emulsion Using a Polyu-rethane Foam Bed[J].Ind.Eng.Chem.Res.,1997,36:4949-4953.
• [6]GB8978-1996.污水排放综合标准[S].