谷晓阳,苏林,李康,杨忠诚,张超波
GU Xiaoyang,SU Lin,LI Kang,YANG Zhongcheng,ZHANG Chaobo

• 1:上海理工大学能源与动力工程学院

摘要(Abstract)：

针对电动汽车热泵系统室外换热器结霜会使系统性能严重衰减且不稳定性加剧等问题，在研究目前汽车上普遍使用的逆循环除霜模式的基础上，设计并搭建了应用于电动汽车的热气旁通除霜系统，试验研究了两种模式在不同环境工况下的除霜性能，分析了两种除霜模式的运行特性，并估算了两种除霜模式下的电动汽车续航里程。结果表明：在5～-5℃的环境工况下，逆循环除霜用时80～400 s，除霜过程平均功耗618～1 008 W；热气旁通除霜用时350～600 s，系统功耗1 383～1 621 W。相比于逆循环除霜，热气旁通除霜用时增加200～270 s，功耗上升613～765 W，续航里程减少1.9%～3.8%，但在除霜过程中有利于保证乘员舱内的舒适性。在室外环境温度低于0℃时，除霜过程中关闭室外换热器风机，能减小空气侧换热损失，提高除霜效率。
In view of the problem that outdoor heat exchanger frosting of electric vehicle heat pump system will seriously degrade the system performance and increase the instability,based on the study of the reverse cycle defrosting mode commonly used in automobiles,a hot gas bypass defrosting system was designed and built. The defrosting performance of the two modes under different environmental conditions was experimentally studied,and the operation characteristics of the two defrosting modes were analyzed,and the range of electric vehicle under two defrosting modes was estimated by theoretical derivation. The results show that,at 5 ～-5 ℃ ambient temperature,the reverse cycle defrosting time is 80～400 s,and the average power consumption during the defrosting is 618～1 008 W. The hot gas bypass defrosting takes 350～600 s,and the average power consumption is 1 383～1 621 W. Compared with the reverse cycle defrosting,the hot gas bypass defrosting time increases by 200～270 s,the power consumption increases by 613～765 W,and the range decreases by 1.9%～3.8%. However,it is beneficial to ensure the comfort in the cabin during the defrosting process. When the ambient temperature is below 0 ℃,closing the outdoor heat exchanger fan during the defrosting process can reduce the air side heat transfer loss and improve the defrosting efficiency.

关键词(KeyWords)： 电动汽车;室外换热器;热气旁通除霜;逆循环除霜;续航里程
electric vehicle;outdoor heat exchanger;hot gas bypass defrosting;reverse cycle defrosting;driving range

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金青年基金项目（51906158）

作者(Author): 谷晓阳,苏林,李康,杨忠诚,张超波
GU Xiaoyang,SU Lin,LI Kang,YANG Zhongcheng,ZHANG Chaobo

参考文献(References)：

• [1] HANNAN M A,AZIDIN F A,MOHAMED A.Hybrid electric vehicles and their challenges:A review[J].Renewable and Sustainable Energy Reviews,2014,29:135-150.
• [2] TIE S F,TAN C W.A review of energy sources and energy management system in electric vehicles[J].Renewable and Sustainable Energy Reviews,2013,20(4):82-102.
• [3] ZHANG Z Y,WANG J Y,FENG X,et al.The solutions to electric vehicle air conditioning systems:A review[J].Renewable and Sustainable Energy Reviews,2018,91(C):443-463.
• [4] KIM K Y,KIM S C,KIM M S.Experimental studies on the heating performance of the PTC heater and heat pump combined system in fuel cells and electric vehicles[J].International Journal of Automotive Technology,2012,13:971-977.
• [5] NASR M,FAUCHOUX M,BESANT R,et al.A review of frosting in air-to-air energy exchangers[J].Renewable and Sustainable Energy Reviews,2014,30:538-554.
• [6] WANG W,FENG Y,ZHU J,et al.Performances of air source heat pump system for a kind of mal-defrost phenomenon appearing in moderate climate conditions[J].Applied Energy,2013,112:1138-1145.
• [7]包佳倩，苏林，刘明康，等.电动汽车热泵空调系统室外换热器结霜特性实验研究[J].制冷学报，2020,41(3):58-64.BAO J Q,SU L,LIU M K,et al.Experimental study on outdoor heat exchanger frosting characteristics of a heat pump air conditioning system for electric vehicle[J].Journal of Refrigeration,2020,41(3):58-64.
• [8] GUO X M,CHEN Y G,WANG W H,et al.Experimental study on frost growth and dynamic performance of air source heat pump system[J].Applied Thermal Engineering,2008,28(17-18):2267-2278.
• [9] SONG M J,DENG S M,DANG C B,et al.Review on improvement for air source heat pump units during frosting and defrosting[J].Applied Energy,2018,211:1150-1170.
• [10] MELO C,KNABBEN F T,PEREIRA P V.An experimental study on defrost heaters applied to frostfree household refrigerators[J].Applied Thermal Engineering,2013,51(1-2):239-245.
• [11] STEINER A,RIEBERER R.Parametric analysis of the defrosting process of a reversible heat pump system for electric vehicles[J].Applied Thermal Engineering,2013,61(2):393-400.
• [12] HUANG D,LI Q X,YUAN X L.Comparison between hot-gas bypass defrosting and reverse-cycle defrosting methods on an air-to-water heat pump[J].Applied Energy,2009,86(9):1697-1703.
• [13] LIANG C H,ZHANG X S,LI X W,et al.Control strategy and experimental study on a novel defrosting method for air-source heat pump[J].Applied Thermal Engineering,2010,30(8-9):892-899.
• [14]陈恩林，江斌，刘向农，等.热气旁通制冷系统的数值模型建立与分析[J].低温与超导，2017,45(4):72-77.CHEN E L,JIANG B,LIU X N,et al.Establishment and analysis of numerical model of hot gas bypass refrigeration system[J].Cryogenics&Superconductivity,2017,45(4):72-77.
• [15]潘乐燕，王天英，牛凤仙，等.车用热泵系统结霜化霜实验研究[J].制冷学报，2020,41(6):47-54.PAN L Y,WANG T Y,NIU F X,et al.Experimental study on frosting and defrosting of vehicle heat pump system[J].Journal of Refrigeration,2020,41(6):47-54.
• [16]董军启，张光华，唐钦远，等.电动汽车热泵空调冷凝蒸发器的特性实验研究[J].制冷学报，2019,40(6):118-124.DONG J Q,ZHANG G H,TANG Q Y,et al.Experimental investigation on the performance of evaporator/condenser in a heat pump air conditioner for electric vehicle[J].Journal of Refrigeration,2019,40(6):118-124.
• [17]朱建民，王丹东，陈江平.环境参数对平行流蒸发器结霜动态性能的影响[J].制冷技术，2017,37(2):44-50.ZHU J M,WANG D D,CHEN J P.Effects of environmental parameters on frosting dynamic performance of parallel flow evaporator[J].Chinese Journal of Refrigeration Technology,2017,37(2):44-50.
• [18] LEE D.Experimental study on the heat pump system using R134a refrigerant for zero-emission vehicles[J].International Journal of Automotive Technology,2015,16(6):923-928.
• [19]张子琦.电动汽车热泵空调系统及降能耗策略研究[D].上海：上海交通大学，2018.ZHANG Z Q.Study on electric vehicle heat pump air conditioning system and energy consumption reduction strategy[D].Shanghai:Shanghai Jiao Tong University,2018.