刘志斌,吴荣华
LIU Zhi-bin,WU Rong-hua

• 1:青岛大学
• 2:大连民族大学

摘要(Abstract)：

针对污垢沉积引起换热管阻力变化的问题,建立了换热管内污水流动阻力变化的数学模型.本文提出管内污水流动的沿程阻力系数为洁净状态下换热管内污水的初始流速和时间的函数模型。基于此模型,通过理论推导获得了换热管内污水流动的沿程阻力系数表达式,分析了不同流动状态下沿程阻力系数的影响因素。通过试验获得了换热管污染后管内沿程阻力系数的半经验公式。结果表明:在考虑污垢底层影响时,管内污水流动的沿程阻力系数与洁净状态下管内污水初始流速和运行时间有关;该关系可用粘性底层的厚度和污垢厚度来表示。
In order to analyze the inner-tube sewage flow resistance is effected by the fouling,the mathematical model of the frictional resistance coefficient is established.In this paper,the initial velocity in the no-fouling condition and the running-time is seen as the influence factors to the flow resistance coefficient.According to the model,the formula of the sewage flow resistance coefficient in the heat exchange tube is obtained through the theoretical derivation and the experimental.The results show that the hypothesis is correct and the sewage flow resistance coefficient is expressed through the thickness of viscous sublayer and the thickness of fouling.

关键词(KeyWords)： 阻力特性;污垢;热泵
flow resistance characteristics;fouling;heat pump

Abstract:

Keywords:

基金项目(Foundation): 中国博士后科学基金面上资助项目(2016M602096)

作者(Author): 刘志斌,吴荣华
LIU Zhi-bin,WU Rong-hua

参考文献(References)：

• [1]张吉礼,马良栋.污水源热泵空调系统污水侧取水、除污和换热技术研究进展[J].暖通空调,2009,39(7):41-47.
• [2]杨灵艳,朱清宇,路宾,等.污水源热泵中心能源站设计研究[J].暖通空调,2012,42(4):31-34.
• [3]H.O.Lindstrm.Experiences with a 3.3 MW heat pump using sewage water as heat source[J].Journal of Heat Recovery Systems,1985,5(1):33-38.
• [4]Arashi Norio and Inaba Atsushi.Evaluation of energy use in district heating and cooling plant using sewage and one using air as heat source[J].Journal of the Japan Institute of Energy,2000,79(5):446-454.
• [5]Yong Cho,Rin Yun.A raw water source heat pump airconditioning system[J].Energy and Buildings,2011,43:3068-3073.
• [6]Lanbin Liu,Lin Fu,Yi Jiang.Application of an exhaust heat recovery system for domestic hor water[J].Energy,2010,35:1476-1481.
• [7]Baek N C,Shin U C,Yoon J H.A study on the design and analysis of heat pump heating system using wastewater as a heat source[J].Solar Energy,2005,78:427-440.
• [8]孙德兴,张承虎,庄兆意.污水源热泵供暖空调中的新概念与新名词[J].暖通空调,2010,40(6):126-129.
• [9]Funamizu N,Iida M,Sakakura Y.Reuse of heat energy in waste water:implementation examples in Japan[J].Water Science and Technology,2001,43(10):277-286.
• [10]刘志斌.双级泵无外挡板污水采集装置防阻塞特性的研究[D].哈尔滨:哈尔滨工业大学,2006:64-72.
• [11]刘志斌.污水源热泵系统取水换热工艺中污水流动与换热特性研究[D].大连:大连理工大学,2014:58-65.
• [12]李伟,杨笑瑾,马东华,等.镍基合金换热管分段式机械胀接试验[J].压力容器,2015,32(9):75-79.
• [13]王腾飞,王腾帅,张宗艳.基于负反馈低通滤波器的设计[J].机电工程,2015,32(9):1267-1270.
• [14]赵玺灵,付林,张世钢,等.城市原生污水源热泵系统的应用[J].太阳能学报,2010,31(11):1458-1462.