制冷系统变工况性能数值模拟与实验研究Numerical Simulation and Experimental Study on Working Process of Refrigeration System
任悦,郭宪民,樊海彬
REN Yue~1,GUO Xian-min~2,FAN Hai-bin~3(1.Tianjin Polytechnic Unirersity
摘要(Abstract)：
采用分布参数的方法建立了制冷系统的数学模型,在建立冷凝器和蒸发器两相区模型时采用了分相流模型,并考虑了流型变化对制冷剂流动换热过程的影响。利用所建模型,计算分析了冷凝器进口空气温度、蒸发器进口空气温度等参数变化对系统性能的影响,在焓差实验室对一台风冷热泵空调器性能进行了实验研究,得出了冷凝器和蒸发器进口空气温度随冷凝压力、蒸发压力、过冷度和过热度的变化曲线。将理论计算结果与实验结果进行对比分析,结果证实了所建仿真模型是合理的。
Mathematic model of the refrigeration system is presented with applying the distributed parameters method.In the models of condenser and evaporator,the flow patterns and its effects on the heat transfer coefficients of refrigerant side are considered.And the influence of inlet air temperature of condenser and evaporator on cycle system is analyzed in detail,and an experimental study has been conducted in the enthalpy difference test set-up.The lines of the inlet air temperature of condenser and evaporator changed with the condensation pressure,evaporation pressure,super cooling degree and superheating degree.The comparing of the calculation results with the experiment at the same state has verified the accurate of the model.
关键词(KeyWords)：
制冷系统;变工况性能;实验研究
refrigeration system;working process;experimental study
基金项目(Foundation):
作者(Author):
任悦,郭宪民,樊海彬
REN Yue~1,GUO Xian-min~2,FAN Hai-bin~3(1.Tianjin Polytechnic Unirersity
参考文献(References)：
- [1]MacArthur J W,Grald E W.Unsteady Compressible Two-phase Flow Model for Predicting Gyclic Heat Pump Perfor-mance and a Comparison with Experimental Data[J].Int.J.Refrig,1989,(12):29-41.
- [2]Hamilton J F,Miller J L.A Stimulation Program for Mod-elling and Air conditioning System[J].ASHARE Trans,1990,96
- [3]葛云亭,彦启森,彭雄兵.制冷空调系统仿真数学模型的理论与实验研究[J].制冷学报,1995,4:9-18.
- [4]Wang H,Touber S.Distributed and Non-steady-state Mod-elling of an Air Cooler[J].Int.J Refrig,1991,14:98-111.
- [5]Kempiak M J,Crawford R R,Ph D P E.Three-Zone.Steady-state Modelling of a Mobil Air-conditioning Con-denser[J].ASHARE Trans,1992.part II.No.3587.57-61.
- [6]葛云亭,彦启森.冷凝器动态参数数学模型的建立与理论计算[J].制冷学报,1995,(3):17-26.
- [7]葛云亭,彦启森.蒸发器动态参数数学模型的建立与理论计算[J].制冷学报,1995(1):9-17.
- [8]翁文兵,王瑾竹,蒋能熊.电子膨胀阀的制冷剂流量特性的试验研究[J].流体机械,1998,26(10):58-61.
- [9]Edward P M.Adiabatic Single and Two-phase Flow insmall Bore Tube[J].ASHARE J.1963,5(11):75-86.
- [10]Pate M B,Tree P R.An Analvsis of Pressure and Tempera-ture Measurements Along a Capillary Tube-suction LineHeat Exchanger[J].ASHARE Trans,1984,90:291-301.
- [11]Pate M B,Tree P R.A Liner Quality Model for CapillaryTube-suction Line Heat exchanger[J].ASHARETrans,1984,90:3-17.
- [12]Rice C K.The Effect of Void Fraction Correlation and HeatFlux Assumption on Refrigerant Charge Inventory Predictions[J].ASHARE Trans,1987,93(1):341-367.
- [13]Mohsen Farzad,Dennis L O’Neal.System Performance Char-acteristics of Air Conditioner Over a Range of Charging Condi-tions[J].Int.J.Refrig,1991,14:321-328.
- [14]Ren Yue Numerical Simulation on Working Process of Refrigeration System of Evaporator Calorimeter[A].Proceedings ofthe 5th International Conference on Compressor and Refriger-ation[C].2005:355-363.
- [15]Dabiri A E,Rice C K.A Compressor simulation methodwith corrections for the level of suction gas superheat[J].ASHRAE Trans,1981,187(2):771-782.
- [16]丁国良,张春路.制冷空调装置仿真与优化[M].北京:科学出版社,2001.