宋力钊,刘圣春,饶志明
SONG Li-zhao,LIU Sheng-chun,RAO Zhi-ming

• 1:天津商业大学机械工程学院天津市制冷技术重点实验室

摘要(Abstract)：

对刮片式冰浆生成器进行试验研究,探讨不同浓度下的氯化钠溶液结晶的试验过程与现象。试验结果表明:对浓度为3%~5%的氯化钠溶液制取冰浆,能效系数最高达到1.9。纯净水和氯化钠溶液在试验过程中,存在一定的过冷度下才开始结晶,并且随着浓度的增加冰点温度呈线性减小,与理论相比,由于氯化钠溶液在低温下容易发生析晶,试验得到的溶液结晶点温度比理论的温度要高一些。
The scraped surface ice generator experimental studied,The different concentrations of sodium chloride solution crystallization experiments processes and phenomena was discussed.The experimental results show that:For a concentration of 3% to 5% sodium chloride solution was prepared to take the ice slurry,the highest energy efficiency coefficient can reached to 1.9.Purified water and sodium chloride solution during the experiment,there is a certain degree of sub cooling before crystallization began,and with increasing concentrations of the freezing temperature linearly decrease,compared with the theoretical,since the salt solution of sodium chloride at a low temperature prone to crystallization,under the experimental solution crystallization point temperature is higher than the theoretical temperature

关键词(KeyWords)： 刮片式;蓄冷剂;氯化钠;能效分析
scraped surface ice generation;storage material;sodium chloride;energy efficiency analysis

Abstract:

Keywords:

基金项目(Foundation):

作者(Author): 宋力钊,刘圣春,饶志明
SONG Li-zhao,LIU Sheng-chun,RAO Zhi-ming

参考文献(References)：

• [1]Ise H,Tanino M,Kozawa Y.Ice storage system in Kyoto station building[C].Information Booklet for the Technical Tour of the Fourth Workshop of IIR Ice Slurry Working Party,2001,(13):6-11.
• [2]J Quarini.Ice-pigging to reduce and remove fouling and to achieve clean-in-place[J].Applied Thermal Engineering,2002,(22):747-753.
• [3]M Kauffeld,M J Wang,V Goldstein.Ice slurry applications[J].International Journal of Refrigeration,2010,(33):1491-1505.
• [4]Farid MM,Khalaf AN.Performance of direct contact latent heat storage units with two hydrated salts[J].Solar Energy,1994,52:179-189.
• [5]Lane GA.Phase change materials for energy storage nucleation to prevent subcooling[J].Solar Energy Mater Solar Sell,1991,27:135-160
• [6]李兴仁,童明伟,吴碧容.共晶盐低温蓄冷材料的试验[J].重庆大学学报,2004,27(8):114.
• [7]李兴仁.低温相变蓄冷材料及其蓄冷特性的试验研究[J].低温相变蓄冷材料,2004,(5):3-4.
• [8]李达志,崔海亭,刘凤青,等.填充泡沫铜对石蜡相变蓄热性能的试验研究[J].流体机械,2012,40(5):61-64.
• [9]杨俊兰,马一太,李敏霞,等.亚临界CO2流体性质及沸腾相变特性分析[J].流体机械,2011,39(10):67-72.
• [10]Abhat A.Low temperature latent heart thermal energy storage:heat storage materials[J].Solar Energy,1983,30:313-332.
• [11]化学工业部天津化工研究院.化工产品手册[M].北京:化学工业出版社,1993.