程建路,胡开永,汪倍倍,朱婷婷
CHENG Jianlu,HU Kaiyong,WANG Beibei,ZHU Tingting

• 1:天津商业大学天津市制冷技术重点实验室

摘要(Abstract)：

为了提高亚临界CO_2系统压缩机工作效率，搭建了亚临界CO_2制冷系统实验台，分析了频率、吸气压力及过热度对压缩机容积效率及系统性能的影响。结果表明，随压缩机频率的增加，制冷系统COP减小，当压缩机频率从30 Hz增大至70 Hz时，系统COP降低了22.37%；压缩机吸气压力升高时，制冷系统COP呈上升趋势，当吸气压力从1.63 MPa增加到1.74 MPa，COP增长率为2.58%；压缩机吸气过热度增加时，系统COP逐渐减小；压缩机容积效率随吸气压力增大而增大，吸气过热度对容积效率影响较小。
In order to improve the efficiency of the compressor of subcritical CO_2 system，a subcritical CO_2 refrigeration system test bench was built to analyze the influences of frequency，suction pressure and superheat on the volumetric efficiency of the compressor and system performance.The results show that as the compressor frequency increases，the refrigeration system COP decreases.When the compressor frequency increases from 30 Hz to 70 Hz，the system COP decreases by 22.37%；When the compressor suction pressure increases，the refrigeration system COP shows an upward trend，when the suction pressure increases from 1.63 MPa to 1.74 MPa，the COP growth rate is 2.58%；The compressor volumetric efficiency increases with the suction pressure，and the degree of gas superheat has little effect on volumetric efficiency.

关键词(KeyWords)： 亚临界;容积效率;吸气压力;吸气过热度
subcritical;volumetric efficiency;inspiratory pressure;inspiratory superheat

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金青年基金项目(51906177)

作者(Author): 程建路,胡开永,汪倍倍,朱婷婷
CHENG Jianlu,HU Kaiyong,WANG Beibei,ZHU Tingting

参考文献(References)：

• [1]ROBINSON D M，GROLL E A.Efficiencies of transcritical CO2 cycles with and without an expansion turbine[J].International Journal of Refrigeration，1998(21)：577-589.
• [2]CECCHINATO L，CORRADI M，FORNASIERI E，et al.Carbon dioxide as refrig-erant for tap water heat pumps：A comparison with the traditional solution[J].International Journal of Refrigeration，2005(28)：1250-1258.
• [3]黄龙飞，曹锋.跨临界CO2循环中过冷强化技术的发展综述[J].流体机械，2021，49(1)：88-96.HUANG L F，CAO F.Review of the development of subcooling enhancement technology in transcritical CO2 cycle[J].Fluid Machinery，2021，49(1)：88-96.
• [4]SARKAR J，BHATTARYYA S，GOPAL M R.Natural refrigerent-based subcritical and transcritical cycles for high temperature heating[J].International Journal of Refrigeration，2007(30)：3-10.
• [5]BAEK J S，GROLL E A，LAWLESS P B.Pistonecylinder work producing expansion device in a carbon dioxide cycle.part I：experimental investigation[J].International Journal of Refrigeration，2005(28)：141-151.
• [6]BAEK J S，GROLL E A，LAWLESS P B.Pistonecylinder work producing expansion device in a carbon dioxide cycle.part II：theoretical investigation[J].Interna-tional Journal of Refrigeration，2005(28)：152-164.
• [7]申江，汪倍倍，周成君，等.CO2亚临界制冷系统热力学性能分析[J].低温与超导，2018，46(12)：95-99.SHEN J，WANG B B，ZHOU C J，et al.Thermodynamic analysis of the CO2 subcritical refrigeration system[J].Cryogenics & Superconductivity，2018，46(12)：95-99.
• [8]杨俊兰，沈士杰，高思雨，等.CO2跨临界循环与传统制冷循环的性能比较[J].流体机械，2019，47(1)：80-83.YANG J L，SHEN S J，GAO S Y，et al.Performance comparison between CO2 transcritical cycle and conventional refrigeration cycle[J].Fluid Machinery，2019，47(1)：80-83.
• [9]申江，郝嘉临，赵瑞杰，等.容量调节比对变容量复叠制冷系统性能影响研究[J].低温工程，2020，233(1)：40-45.SHEN J，HAO J L，ZHAO R J，et al.Effect of capacity adjustment ratio on performance of variable capacity cascade refrigeration system[J].Cryogenic Engineering，2020，233(1)：40-45.
• [10]韩毅，吴静怡，HAFNER ARMIN.大功率CO2压缩机运行效率的实验研究[J].制冷学报，2017，38(3)：7-12.HAN Y，WU J Y，HAFNER A.Experimental investigation of high-power CO2 compressor efficiencies at varied revolutions[J].Journal of Refrigeration，2017，38(3)：7-12.
• [11]王淞，赵建平.长管拖车气瓶用4130X钢的应变疲劳特性及寿命预测[J].压力容器，2020，37(3)：9-14.WANG S，ZHAO J P.Strain fatigue characteristics and life prediction of steel 4130X for tube trailer gas cylinder[J].Pressure Vessel Technology，2020，37(3)：9-14.
• [12]温智炜，闫素英，苏世良，等.基于流固耦合的旋转轴唇型油封流场特性及泵汲率研究[J].流体机械，2020，48(4)：6-11.WEN Z W，YAN S Y，SU S L，et al.Study on flow field characteristics and pump drainage rate of rotary shaft-lip seal based on fluid-solid coupling[J].Fluid Machinery，2020，48(4)：6-11.
• [13]BUDINIS S，THORNHILL N F.Supercritical fluid recycle for surge control of CO2 centrifugal compressors[J].Computers and Chemical Engineering，2016，91：329-342.