吴小华,魏闻天,宋衍昌,李晓琼,张振涛,郑康辉,杨俊玲
WU Xiaohua,WEI Wentian,SONG Yanchang,LI Xiaoqiong,ZHANG Zhentao,ZHENG Kanghui,YANG Junling

• 1:北京石油化工学院机械工程学院深水油气管线关键技术与装备北京市重点实验室
• 2:中国科学院理化技术研究所中国轻工业食品药品保质加工储运装备与节能技术重点实验室
• 3:中科碳冷(无锡)高科技有限公司

摘要(Abstract)：

为了研究应用于人工冰场的跨临界CO_2并联压缩制冷系统性能，搭建了跨临界CO_2并联压缩制冷系统，试验研究了单压缩机独立运行以及双压缩机并联运行时，蒸发温度与压缩机运行频率对系统COP、制冷量、压缩机功率、制冷剂流量、压比的影响。结果表明，随蒸发温度升高，COP、制冷量、压缩机功率和制冷剂流量均增大，压比减小，蒸发温度为-9.4℃时，COP达到本试验的最大值2.00；在试验工况40～60 Hz范围内，随着压缩机运行频率增加，制冷量、压缩机功率、制冷剂流量和压比均增大；单台压缩机独立运行和并联压缩时，COP均在50 Hz达到最大，且并联压缩COP随压缩机运行频率差的增加而降低，最大可相差26.67%。建立了系统COP预测模型，通过蒸发温度与排气压力对COP进行预测，并与并联压缩试验结果进行了对比，所构建模型预测结果与同频率并联压缩系统试验测得COP平均误差为3.7%。研究结果可为并联压缩制冷系统设计提供借鉴和指导。
In order to explore the performance of transcritical CO_2 parallel compression refrigeration applied to artificial ice rink,a transcritical CO_2 parallel compression refrigeration system was established. Effects of evaporation temperature and compressor frequency on COP,cooling capacity,compressor power consumption,refrigerant flow rate and compression ratio were analyzed when single compressor runs independently and two compressors runs in parallel. The results indicate that COP,cooling capacity,compressor power consumption and refrigerant flow increase with the increase of evaporation temperature,and the compression ratio decreases.When the evaporation temperature is-9.4 ℃,COP reaches the maximum value of 2.00 for this test. In the range of 40～60 Hz test condition,with the increase of compressor frequency,the cooling capacity,compressor power consumption,refrigerant flow rate and compression ratio all increase. When a single compressor runs independently or the parallel compressors run at the same time,the COP reaches the maximum value at 50 Hz. At the same time,COP decreases with the increase of compressor operating frequency difference,and the COP difference can reach max. 26.67%.A prediction model for the system was established to predict COP by evaporation temperature and discharge pressure.The predicted results were compared with the test results of the parallel compressors. The average error between the results predicted by the built model and the COP measured in the parallel compressor system test at the same frequency is 3.7%. The research results provide reference and guidance for the design of parallel compression refrigeration system.

关键词(KeyWords)： 并联压缩;CO_2;人工冰场;预测模型
parallel compression;CO_2;artificial ice rink;prediction model

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金项目（52206032）;; 中央引导地方科技发展专项资金项目（ZYYD2022B11,2022ZY0048）;; 中国科学院稳定支持基础研究领域青年团队计划项目（YSBR-043）

作者(Author): 吴小华,魏闻天,宋衍昌,李晓琼,张振涛,郑康辉,杨俊玲
WU Xiaohua,WEI Wentian,SONG Yanchang,LI Xiaoqiong,ZHANG Zhentao,ZHENG Kanghui,YANG Junling

参考文献(References)：

• [1] ROBINSON D M,GROLL E A.Efficiencies of transcritical CO2 cycles with and without an expansion turbine[J].International Journal of Refrigeration,1998(21):577-589.
• [2]宋昱龙，王海丹，殷翔，等.跨临界CO2蒸气压缩式制冷与热泵技术综述[J].制冷学报，2021,42(2):1-24.SONG Y L,WANG H D,YIN X,et al.Review of transcritical CO2 vapor compression technology in refrigeration and heat pump[J].Journal of Refrigeration,2021,42(2):1-24.
• [3]杨俊兰，沈士杰，高思雨，等.CO2跨临界循环与传统制冷循环的性能比较[J].流体机械，2019,47(1):80-83.YANG J L,SHEN S J,GAO S Y,et al.Performance comparison between CO2 transcritical cycle and conventional refrigeration cycle[J].Fluid Machinery,2019,47(1):80-83.
• [4]谢鸿玺，王炳忠，刘宏丽，等.冬奥冰雪场馆关键制冷设备研究[J].低温与超导，2022,50(10):76-80.XIE H X,WANG B Z,LIU H L,et al.Research on key refrigeration equipment for winter Olympics ice and snow stadium[J].Cryogenics&Superconductivity,2022,50(10):76-80.
• [5]刘楷.自然工质CO2在2022年北京冬奥会冰场的运用[J].制冷技术，2020,40(2):20-24.LIU K.Application of natural refrigerant CO2 in ice rinks of beijing winter olympics in 2022[J].Chinese Journal of Refrigeration Technology,2020,40(2):20-24.
• [6] ROGSTAM J,SAWALHA S,NILSSON P.Ice rink refrigeration system with CO2 as secondary fluid[C]//Applied Thermodynamics and Refrigeration.Proceedings of IIR International Conference on Thermophysical Properties and Transfer Processes of Refrigerants.Vicenza:Applied Thermodynamics and Refrigeration,2005:1-8.
• [7] SIMARD L.Ice rink uses CO2 system[J].Ashrae Journal,2012,54(3):38-44.
• [8]孟凡宇，赵宝国，姜伟涛，等.自然工质CO2在人工滑雪场项目上的应用[J].冷藏技术，2018,41(3):37-40.MENG F Y,ZHAO B G,JIANG W T,et al.Application of natural refrigerant CO2 in the project of artificial ski resort[J].Journal of Refrigeration Technology,2018,41(3):37-40.
• [9]马一太，王派.2022年北京冬奥会国家速滑馆CO2制冷系统和国家雪车雪橇中心氨制冷系统的简介[J].制冷技术，2020,40(2):2-7.MA Y T,WANG P.Brief introduction of CO2refrigeration system in the national speed skating stadium and ammonia refrigeration system in the national snowmobile sled center for Beijing Winter Olympics in 2022[J].Chinese Journal of Refrigeration Technology,2020,40(2):2-7.
• [10]王冠邦，张信荣.0℃以上人工造雪中的CO2热力学系统研究[J].制冷技术，2020,40(2):38-45.WANG G B,ZHANG X R.Study on thermodynamic systems using carbon dioxide for snowmaking at the ambient temperature of above 0℃[J].Chinese Journal of Refrigeration Technology,2020,40(2):38-45.
• [11]王栋，梅申功，陈卓，等.CO2跨临界双级循环制冷系统最优中间压力的热力学分析[J].流体机械，2022,50(6):31-38.WANG D,MEI S G,CHEN Z,et al.Thermodynamic analysis of optimum intermediate pressure in a refrigerated cabinet with CO2 transcritical two-stage cycle[J].Fluid Machinery,2022,50(6):31-38.
• [12] MA Y,LIU Z,TIAN H.A review of transcritical carbon dioxide heat pump and refrigeration cycles[J].Energy,2013,55:156-172.
• [13]申道明，桂超，夏锦红，等.并联压缩机组制冷系统性能试验分析[J].流体机械，2020,48(9):77-82.SHEN D M,GUI C,XIA J H,et al.Experimental analysis on refrigerating system performance of a parallel unit with several compressors[J].Fluid Machinery,2020,48(9):77-82.
• [14]程建路，胡开永，汪倍倍，等.亚临界CO2系统压缩机性能试验研究[J].流体机械，2022,50(6):6-10.CHENG J L,HU K Y,WANG B B,et al.Experimental research on compressor performance of subcritical CO2system[J].Fluid Machinery,2022,50(6):6-10.
• [15]申长春，刘业凤，胡继伟，等.跨临界CO2空气源热泵系统运行性能研究[J].化学工程，2022,50(6):6-10.SHEN C C,LIU Y F,HU J W,et al. System performance of air-source transcritical CO2 heat pump[J].Chemical Engineering(China),2022,50(6):6-10.
• [16]宋昱龙，唐学平，王守国，等.空气源跨临界CO2热泵最优排气压力的理论和实验[J].西安交通大学学报，2014,48(9):81-87.SONG Y L,TANG X P,WANG S G,et al.Theoretical and experimental investigation for optimal discharge pressure of air-source trans-critical CO2 heat pump[J].Journal of Xi'an Jiaotong University,2014,48(9):81-87.