高波;王孝军;倪丹;周文杰;刘凯;
GAO Bo;WANG Xiao-jun;NI Dan;ZHOU Wen-jie;LIU Kai;Jiangsu University;Shenyang Blower Group Nuclear Power Pump Co.,Ltd.;

• 1:江苏大学
• 2:沈阳鼓风机集团核电泵业有限公司

摘要(Abstract)：

为探究变转速运行对离心泵压力脉动的影响,以1台比转速为95的单级单吸离心泵为研究对象,利用高频动态压力传感器,同步采集泵进、出口及蜗壳周向不同位置处变转速下的压力脉动信号,并开展相似工况下压力脉动信号频谱特性分析。试验结果表明:相似工况下,随转速提高,轴频、叶频及其倍频的压力脉动幅值均增大;对压力脉动幅值无量纲化,发现轴频及叶频处各测点压力脉动系数随转速的变化规律存在差异性,但各测点压力脉动系数的平均值却几乎不受转速影响,并且各测点在整个低频段(0⁴ f_(BPF))的压力脉动能量平均值亦随转速变化不显著,表明压力脉动系数和能量平均值可作为衡量泵动态特性的参数;流量对泵动态特性影响显著,从0.6Q增加至1.3Q,各转速下泵压力脉动能量平均值呈先减小再增大趋势。
In order to study the effect of variable rotating speeds on the pressure pulsation of a centrifugal pump,a singlestage single-suction centrifugal pump with a specific speed of 95 was employed as the research object.Pressure pulsation signals at the locations of the pump inlet,outlet and spiral case were measured at various speeds using high-frequency dynamic pressure sensors,and frequency spectrum characteristics of the pressure pulsation signals under similar operating conditions were analyzed. The experimental results show that under similar conditions,the amplitudes of rotating shaft frequency,blade passing frequency and its second harmonic frequency increase with the increase of rotating speeds. As for the non-dimensionalization of pressure pulsation amplitude,the pressure pulsation coefficients vary with the rotating speeds at the rotating shaft frequency and blade passing frequency,but the average values of the pressure pulsation coefficient of each measuring point are almost independent of the rotating speed. The average values of the pressure pulsation energy over the whole low frequency band(04 f_(BPF))的压力脉动能量平均值亦随转速变化不显著,表明压力脉动系数和能量平均值可作为衡量泵动态特性的参数;流量对泵动态特性影响显著,从0.6Q增加至1.3Q,各转速下泵压力脉动能量平均值呈先减小再增大趋势。
In order to study the effect of variable rotating speeds on the pressure pulsation of a centrifugal pump,a singlestage single-suction centrifugal pump with a specific speed of 95 was employed as the research object.Pressure pulsation signals at the locations of the pump inlet,outlet and spiral case were measured at various speeds using high-frequency dynamic pressure sensors,and frequency spectrum characteristics of the pressure pulsation signals under similar operating conditions were analyzed. The experimental results show that under similar conditions,the amplitudes of rotating shaft frequency,blade passing frequency and its second harmonic frequency increase with the increase of rotating speeds. As for the non-dimensionalization of pressure pulsation amplitude,the pressure pulsation coefficients vary with the rotating speeds at the rotating shaft frequency and blade passing frequency,but the average values of the pressure pulsation coefficient of each measuring point are almost independent of the rotating speed. The average values of the pressure pulsation energy over the whole low frequency band(0⁴ f_(BPF)) do not change with the rotational speed as well,indicating that the average values of pressure pulsation coefficients and the energy can be used as parameters to qualify the pump dynamic characteristics. The effect of flow rate on the dynamic characteristics of the pump was significant,increased from 0.6 Q to 1.3 Q,the average value of pump pulsation energy at each speed decreases first and then increases.

关键词(KeyWords)： 离心泵;变转速;压力脉动;试验研究
centrifugal pump;variable rotating speeds;pressure pulsation;experimental study

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金资助项目(51576090,51706087);; 江苏省高校优势学科建设工程资助项目

作者(Authors): 高波;王孝军;倪丹;周文杰;刘凯;
GAO Bo;WANG Xiao-jun;NI Dan;ZHOU Wen-jie;LIU Kai;Jiangsu University;Shenyang Blower Group Nuclear Power Pump Co.,Ltd.;

参考文献(References)：

• [1]裴毅,田莉,杨晓珍,等.转速变化对离心泵性能的影响[J].排灌机械工程学报,2007,25(4):9-13.
• [2]Mele J,Guzzomi A,Pan J.Correlation of centrifugal pump vibration to unsteady flow under variable motor speed[J].Mechanics&Industry,2014,15(6):525-534.
• [3]董沛鑫,高明,路东岳,等.变转速工况下离心泵蜗壳辐射噪声变化规律的数值研究[J].振动与冲击,2017,36(13):128-133.
• [4]司乔瑞,袁寿其,袁建平,等.叶片与隔舌干涉对离心泵性能和压力脉动影响的数值研究[J].流体机械,2012,40(8):22-26.
• [5]Keller J,Parrondo J,Barrio R,et al.Effects of the pump-circuit acoustic coupling on the blade-passing frequency perturbations[J].Applied Acoustics,2014,76:150-156.
• [6]蔡建程,Pan Jie,Guzzomi Andrew.变转速工况下离心泵蜗舌处压力波动的试验研究[J].流体机械,2015,43(2):13-16.
• [7]蔡建程,潘杰,Guzzomi Andrew.离心泵隔舌区压力脉动测量与分析[J].农业机械学报,2015,46(6):92-96.
• [8]张金凤,冒杰云,袁寿其,等.变转速工况下汽车冷却水泵内外特性变化规律[J].流体机械,2014,42(8):1-6.
• [9]Blanco E,Raúl M,Perotti B,et al.Fluid dynamic pulsations and radial forces in a centrifugal pump with different impeller diameters[J].American Society of Mechanical Engineers,2005:1461-1470.
• [10]Parrondo J,JoséG,Pérez G,et al.The effect of the operating point on the pressure fluctuations at the blade passage frequency in the volute of a centrifugal pump[J].Journal of Fluids Engineering,2002,124(3):784-790.
• [11]窦唯,刘占生.高速离心泵隔舌对流体激振力的影响研究[J].振动工程学报,2012,25(6):705-713.
• [12]明延锋,郭井加,曹玉良,等.离心泵内流场空化持性的数值模拟研究[J].机电工程,2016,33(6):643-647.
• [13]王松林,谭磊,王玉川.离心泵瞬态空化流动及压力脉动特性[J].振动与冲击,2013,32(22):168-173.
• [14]Barrio R,Parrondo J,Blanco E.Numerical analysis of the unsteady flow in the near-tongue region in a volutetype centrifugal pump for different operating points[J].Computers&Fluids,2010,39(5):859-870.
• [15]张宁.离心泵内部非稳态流动激励特性研究[D].镇江:江苏大学,2016.