赵展,金苏敏
ZHAO Zhan,JIN Su-min(Nanjing University of Technology

• 1:南京工业大学

摘要(Abstract)：

利用Fluent软件对不同管排组合方案下的分离式热管换热器的蒸发段进行了数值模拟,得出并比较了各管排组合方案下的温度分布、速度分布和压力分布图,发现了管排组合主要影响传热能力和温度分布而对压力降的影响很小。模拟结果与传热理论相符,并且印证了理论计算的结论,即:"单对单"方案热回收量最大,但安全效果不好;"整体对整体"方案的安全效果好,但热回收量最小;"混合"方案能同时满足安全效果和较大的热回收量,效果最优。
The evaporator of separate type heat pipe heat exchanger under different schemes of tube arrays combination was simulated by the Fluent software,the various distribution maps of temperature,velocity and pressure were obtained and compared,the phenomenon that tube arrays combination has main influence on heat transfer capacity and temperature distribution and little influence on pressure drop was found.The simulation results agree to the theory of heat transfer,and demonstrate the conclusions of theoretical calculation,i.e.,the single-to-single scheme has most heat transfer capacity and worst safety effect,the entirety-to-entirety scheme has least heat transfer capacity and best safety effect,while the mix scheme has both more heat transfer capacity and better safety effect,its effect in general is optimal.

关键词(KeyWords)： 分离式热管;管排组合;低温腐蚀;数值模拟
separate type heat pipe;tube arrays combination;low temperature corrosion;numerical simulation

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金项目(No.50676041)

作者(Author): 赵展,金苏敏
ZHAO Zhan,JIN Su-min(Nanjing University of Technology

参考文献(References)：

• [1]孙奉仲,吕伟,李淑英,等.电站锅炉热管空气预热器壁温变化预测模型及变工况计算[J].电站系统工程,1998,14(4):3-7.
• [2]何立波,赵黛青,陈恩鉴.热管结构参数对空气预热器最低壁温的影响[J].石油化工设备,2005,34(1):6-8.
• [3]李科群,罗行,马虎根,等.热管空气预热器的调壁温设计[J].动力工程,2005,25(增刊):180-184.
• [4]Park,Jong Heung.Study on thermal performance ofheat pipe for optimum placement of satellite equipment[J].ETRI Journal,1997,19(2):59-70.
• [5]Uddin Ahmed Imtiaz1,Islam A.S.M.Atiqul1,Feroz Chowdhury Md.Effect of geometry on the per-formance of miniature heat pipe[C].IMECE,2007.
• [6]Cao,Yiding,Faghri,Amir.Thermal performance ofheat pipes with localized heat input[J].InternationalJournal of Heat and Mass Transfer,1989,32(7):1279-1287.
• [7]Azad,Mohammadieh,Moztarzadeh.Thermal perform-ance of heat pipeheat recovery system[J].Journal of heat re-covery systems,1985,(5):561-570.
• [8]石定明,金苏敏.热管管排组合对露点腐蚀温度影响研究[J].低温与超导,2009,37(12):56-60.
• [9]李志亮,金苏敏.热管烟气废热LiBr-H2O制冷机热管管排排列与组合对温度分布的影响[J].工程热物理学报,2010,31(5):845-848.
• [10]雷勇.翅片管束传热及阻力特性的三维数值模拟[J].华北科技学院学报,2008,5(3):69-73.