张云,谢培钦,陈孚江,陈海飞
ZHANG Yun,XIE Peiqin,CHEN Fujiang,CHEN Haifei

• 1:江苏新科电器有限公司
• 2:常州大学

摘要(Abstract)：

基于GB/T 21455—2019《房间空气调节器能效限定值及能效等级》试验分析了电子膨胀阀的开度对R32热泵型变频空调系统性能的影响规律,以及相应试验工况下系统的性能参数对全年能源消耗效率APF的计算最优值的探讨。结果表明:电子膨胀阀的开度在一定范围内增加时,系统的额定制冷量提高,额定制热量、额定中间制冷量、额定中间制热量都会下降,对系统的能效比EER和额定中间制冷系数EER_(haf)的影响较小,但对性能系数COP和额定中间制热系数COP_(haf)影响较大。计算APF值时额定制冷消耗功率占比大于额定制冷量;在相同的EER时,额定消耗功率越小,其APF值越高;系统中COP越高,对应的APF值并非越大,应尽量提高系统的额定制热量,才能得到最优的APF值;通过实测低温制冷试验计算得到的APF值相较于默认计算公式的值要高。
Based on GB/T 21455—2019“Minimum allowable values of the energy efficiency and energy efficiency grades for room air conditioners”，the influence rules of the opening of electronic expansion valve on the performance of R32 heat pump inverter air conditioning system were analyzed experimentally，and the optimal value of heat transfer capacity and power consumption for annual performance factor(APF) under corresponding experimental conditions was discussed.The results show that with the increase of the opening of the electronic expansion valve，the rated cooling capacity of the system increases，and the rated heating capacity，the rated intermediate cooling capacity and the rated intermediate heating capacity will all decrease，they will slightly influence the energy efficiency ratio(EER) and the rated intermediate cooling coefficient(EER_(haf)) of the system，but have a greater impact on the coefficient of performance(COP) and the rated intermediate heating coefficient(COP_(haf)).When calculating the APF value，the proportion which the rated cooling power consumption accounts for is greater than the rated cooling capacity；at the same EER，the smaller the rated power consumption，the higher the calculated APF value；the higher the COP value of the system，the corresponding APF value is not the largest，so the optimal APF value should be obtained by increasing the rated heating capacity of the system as much as possible；the value of APF calculated by the measured low-temperature cooling experiment is higher than that calculated by the default formula.

关键词(KeyWords)： 变频空调;APF;R32;低温制冷
inverter air conditioner;APF;R32;low-temperature cooling

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金项目(51906020)

作者(Author): 张云,谢培钦,陈孚江,陈海飞
ZHANG Yun,XIE Peiqin,CHEN Fujiang,CHEN Haifei

参考文献(References)：

• [1]王沣浩，费继友，金立文，等.变频空调器控制系统的技术现状和发展趋势[J].制冷学报，2000(2)：1-6.WANG H H，FEI J Y，JIN L W，et al.Developing tendency and current situation of controlling technology in frequency conversion air conditioner[J].Journal of Refrigeration，2000(2)：1-6.
• [2]韩晓红，陈光明.制冷剂R32的循环性能实验研究[J].制冷与空调，2010，10(2)：68-70.HAN X H，CHEN G M.Expermental study on the cycle performance of refrigerant R32[J].Refrigeration and Air-conditioning，2010，10(2)：68-70.
• [3]王朝鑫，朱兴旺，龚毅，等.R32灌注式替代R410A家用空调的试验研究[J].流体机械，2011，39(7)：65-67.WAN C X，ZHU X W，GONG Y，et al.Experiment research on R32 substituting for R410a in household air conditioning[J].Fluid Machinery，2011，39(7)：65-67.
• [4]邵双全，石文星，李先庭，等.电子膨胀阀与毛细管在变频空调系统中的性能分析[J].流体机械，2001，29(12)：41-43.SHAO S Q，SHI W X，LI X T，et al.Performance analysis of electronic expansion valve and capillary in variable frequency air conditioning system[J].Fluid Machinery，2001，29(12)：41-43.
• [5]虞中旸，陶乐仁，王超，等.低频率下电子膨胀阀调节对制冷系统性能的影响[J].制冷学报，2016，37(6)：91-96.YU Z Y，TAO L R，WANG C，et al.Effect of electronic expansion valve adjustment on performance of refrigeration system at low compression frequency[J].Journal of Refrigeration，2016，37(6)：91-96.
• [6]房间空气调节器能效限定值及能效等级：GB/T 21455—2019[S].北京：中国标准出版社，2019.Minimum allowable values of the energy efficiency and energy efficiency grades of room air conditioners：GB/T21455—2019[S].Beijing：China Standard Press，2019.
• [7]张立智，杨晓，刘丙磊，等.提升热泵型变频空调器APF技术途径的试验研究[J].制冷与空调，2017，17(8)：72-77.ZHANG L Z，YANG X，LIU B L，et al.Experimental study on technical approaches of APF promotion for heat pump frequency-conversion air conditioner[J].Refrigeration and Air-conditioning，2017，17(8)：72-77.
• [8]沈佳敏，吴国明，任滔，等.变频空调器最大APF指标的快速求解方法[J].制冷学报，2019，40(5)：83-89.SHEN J M，WU G M，REN T，et al.Quick prediction of maximum APF for inverter air conditioners[J].Journal of Refrigeration，2019，40(5)：83-89.
• [9]何俊，陶乐仁，虞中旸.基于电子膨胀阀调节的制冷系统湿压缩特性研究[J].轻工机械，2018，36(5)：34-39.HE J，TAO L R，YU Z Y.Study of wet compression characteristics of refrigeration system based on electronic expansion valve adjustment[J].Light Industry Machinery，2018，36(5)：34-39.
• [10]李朝政，秦宪.变频空调毛细管辅助膨胀阀节流对性能的影响[C]//2018年中国家用电器技术大会论文集，2018.LI C Z，QIN X.Effect of throttling on performance of capillary assisted expansion valve for frequency air conditioner[C]//Proceedings of China Home Appliance Technology Conference，2018.
• [11]石文星，王宝龙，邵双全.小型空调热泵装置设计[M].北京：中国建筑工业出版社，2013.SHI W X，WANG B L，SHAO S Q.Design of small capacity air conditioners and heat pumps[M].Beijing：China Architecture & Building Press，2013.