章颢缤,杨景山,蹇钊,宓霄凌,黄其,徐超
ZHANG Haobin,YANG Jingshan,JIAN Zhao,MI Xiaoling,HUANG Qi,XU Chao

• 1:华北电力大学
• 2:浙江高晟光热发电技术研究院有限公司
• 3:中广核太阳能开发有限公司

摘要(Abstract)：

为了解析小尺度周期性扩缩结构流道与脉动流结合的复合强化传热机理，以水为工质，对三角槽道层流脉动流动特性及热量输运规律进行了研究。以“二次流”为切入点、“涡及涡运动”为视角，分析了Strouhal数(St)、脉动振幅(A)等脉动参数对三角槽道层流脉动流动及传热过程的影响，揭示了二次流强度与三角槽道层流脉动流传热的关联性。结果表明：通过调节St与A优化涡旋运动状态，可将场协同角(β)缩减5°以上，增强温度梯度与速度矢量两者的协同性，最大传热效率可提升55%以上；St的设置旨在优化涡心运动路径，存在最优St值，使传热效率提升40%以上；A的设置旨在提升涡旋强度及尺寸，当A<100%时，最大传热效率提升约15%；St和A对于层流脉动传热的影响情况，还可采用二次流强度定量反馈，以寻求较优的St和A匹配数值，有效控制传热效率及能耗量。研究结果可为解决高黏度、低流速等工程环境(如光热电站熔盐系统管路、熔盐电加热器换热管)或者小尺度异型管道的流动及传热问题提供参考。
In order to analyze the composite enhanced heat transfer mechanism of pulsating flow in the small-scale channel of periodic expansion and contraction，the flow characteristics and heat transport rules were studied for the laminar pulsating flow in the triangular grooved channel.By taking“secondary flow”as the starting point，and“vortex and vortex motion”as the viewing angle，the effects of Strouhal number(St) and pulsating amplitude(A) on laminar pulsating flow in the triangular grooved channel and the heat transfer process were analyzed，and the correlation between the intensity of secondary flow and the heat transfer enhancement of laminar flow was revealed.The results show that the field coordination angle(β) can be reduced by more than 5° by adjusting St and A to enhance the synergy between temperature gradient and velocity vector，and the heat transfer efficiency can be improved by more than 55%.Otherwise，St is set to optimize the path of the vortex，and there is an optimal St value which can increase the heat transfer efficiency by more than 40%.Pulsating amplitude is set to improve the strength of the vortex，and the maximum heat transfer efficiency is increased by nearly 15% when A is less than 100%.The effect of Strouhal number and pulsating amplitude on vortex motion can be fed back quantitatively by secondary flow intensity so as to find optimal value matching between St and A，and effectively control heat transfer efficiency and energy consumption.The research results can provide reference for solving the problems of flow and heat transfer in engineering environment(molten salt system pipelines and molten salt electric heater heat exchange pipes of CSP power station) with high viscosity and low flow rate，or in the small-scale special-shaped pipelines.

关键词(KeyWords)： 脉动流;涡旋;二次流;场协同
pulsating flow;vortex;secondary flow;field synergy

Abstract:

Keywords:

基金项目(Foundation): 国家重点研发计划重点专项(2022YFB2405200)

作者(Author): 章颢缤,杨景山,蹇钊,宓霄凌,黄其,徐超
ZHANG Haobin,YANG Jingshan,JIAN Zhao,MI Xiaoling,HUANG Qi,XU Chao

参考文献(References)：

• [1]CHENGCHENG T，EILIS R，BARBARA K，et al.Pulsating Poiseuille flow of a cement slurry[J].International Journal of Non-Linear Mechanics，2021，133：103717.
• [2]刘凤霞.涡旋波流动特性及过程强化[D].大连：大连理工大学，2009.LIU F X.Hydrodynamic characteristics and process enhancement of vortex wave flow[D].Dalian：Dalian University of Technology，2009.
• [3]MOHAMMAD H E，MEHDI B，AMIRHESAM T，et al.A critical review on pulsating flow in conventional fluids and nanofluids：Thermo-hydraulic characteristics[J].International Communications in Heat and Mass Transfer，2021，120：104859.
• [4]STEINKE M E，KANDLIKAR S G.Review of single-phase heat transfer enhancement techniques for application in microchannels，minichannels and microdevices[J].International Journal of Heat and Technology，2004，22(2)：3-11.
• [5]PAISARN N，SONGKRAN W.Experimental study on laminar pulsating flow and heat transfer of nanofluids in micro-fins tube with magnetic fields[J].International Journal of Heat and Mass Transfer，2018，118：297-303.
• [6]LAMBERT A A，CUEVAS S，RíO J A D.Enhanced heat transfer using oscillatory flows in solar collectors[J].Solar Energy，2006，80(10)：1296-1302.
• [7]AMJAD A，MUHANMMAD U，ZAINAB B，et al.Pulsating flow of a micropolar-Casson fluid through a constricted channel influenced by a magnetic field and Darcian porous medium：A numerical study[J].Results in Physics，2020，19：103544.
• [8]YE Q H，ZHANG Y H，WEI J J.A comprehensive review of pulsating flow on heat transfer enhancement[J].Applied Thermal Engineering，2021，196：117275.
• [9]MOLOCHNIKOV V M，MIKHEEV N I，MIKHEEV A N，et al.Heat transfer from a cylinder in pulsating cross-flow[J].Thermophysics and Aeromechanics，2017，24(4)：569-575.
• [10]ZHAN Z K，NIE M L，ZHANG H N，et al.Experimental study on heat transfer enhancement by viscoelastic fluid pulsating flow in copper-based microchannel heat sinks[J].Applied Thermal Engineering，2023，232：121070.
• [11]ZONTUL H，SAHIN B.Experimental investigation of convective heat transfer performance and hydrodynamics of pulsating flow through the rectangular grooved channel[J].Experimental Thermal and Fluid Science，2023，141(1)：110796.
• [12]何雅玲，杨卫卫，赵春凤，等.脉动流动强化换热的数值研究[J].工程热物理学报，2005，26(3)：495-497.HE Y L，YANG W W，ZHAO C F，et al.Numerical study of enhancing heat transfer by pulsating flow[J].Journal of Engineering Thermophysics，2005，26(3)：495-497.
• [13]李燕.凹槽通道中层流脉动流动强化换热的实验研究[D].大连：大连理工大学，2013.LI Y.Experimental study on heat transfer enhancement by pulsating laminar flow in rectangular grooved channels[D].Dalian：Dalian University of Technology，2013.
• [14]贾宝菊，孙发明，卞永宁，等.波壁管内的脉动流动及传质强化的数值模拟[J].化工学报，2009，60(1)：6-14.JIA B J，SUN F M，BIAN Y N，et al.Numerical simulation of pulsatile flow and mass transfer enhancement in a wavy-walled tube[J].CIESC Journal，2009，60(1)：6-14.
• [15]钟英杰，王勋廷，黄其，等.基于场协同理论的脉动流传热机理探究[J].浙江工业大学学报，2015，43(2)：180-184.ZHONG Y J，WANG X T，HUANG Q，et al.A study of heat transfer mechanism in a plusating flow based on field synergy theory[J].Journal of Zhejiang University of Technology，2015，43(2)：180-184.
• [16]XU S L，YANG L L，YUE L，et al.Experimental and numerical investigation of heat transfer for two-layered microchannel heat sink with non-uniform heat flux conditions[J].Heat and Mass Transfer，2016，52(9)：1755-1763.
• [17]XU S L，LI Y，HU X L，et al.Characteristics of heat transfer and fluid flow in a fractal multilayer silicon microchannel[J].International Communications in Heat and Mass Transfer，2016，71：86-95.
• [18]WANG C，XU S，WU Y C.Numerical study of pulsating flow frequency and heat transfer in porous channel heat sink[J].Applied Mechanics and Materials，2013，455：470-473.
• [19]许哲涵，殷泽，金琦，等.三角形与梯形凹槽微通道流动换热特性试验研究[J].流体机械，2023，51(6)：13-18.XU Z H，YIN Z，JIN Q，et al.Experimental study on water flow and heat transfer characteristics in microchannel with triangulargrooves and microchannel with trapezoidal grooves[J].Fluid Machinery，2023，51(6)：13-18.
• [20]冯采柠，梁才航，雷腾跃.内插梯形挡板的交叉三角形波纹板流道的流动与传热研究[J].流体机械，2021，49(6)：50-55.FENG C N，LIANG C H，LEI T Y.Study on heat transfer and flow characteristics of cross-corrugated triangular ducts with trapezoidal baffles[J].Fluid Machinery，2021，49(6)：50-55.
• [21]黄其.小尺度周期性凹槽流道低Reynolds数脉动流的流动及传热特性研究[D].杭州：浙江工业大学，2020.HUANG Q.Analysis of flow and heat transfer characteristics in periodic grooved mini-channel by low reynolds number pulsating flow[D].Hangzhou：Zhejiang University of Technology，2020.
• [22]李晓娜，徐荣吉，吴青平，等.冷却温度对平板脉动热管传热特性影响的试验研究[J].流体机械，2023，51(2)：1-10.LI X N，XU R J，WU Q P，etal.Experimental study on the effect of cooling temperature on heat transfer characteristics of flat pulsatin gheatpipe[J].Fluid Machinery，2023，51(2)：1-10.
• [23]于萍，耿伟轩，邵园园，等.基于场协同理论的高温热管散热模拟分析[J].流体机械，2019，47(3)：84-88.YU P，GENG W X，SHAO Y Y，et al.Simulation and analysis on heat dissipation of high-temperature heat pipe based on field synergy theory[J].Fluid Machinery，2019，47(3)：84-88.
• [24]王永庆，朱冰，赵頔，等.一种强化换热流道的传热特性及流体扩散性分析[J].郑州大学学报，2017，38(1)：41-45.WANG Y Q，ZHU B，ZHAO D，et al.Characteristics of heat transfer and fluid diffusion in a heat transfer enhanced duct[J].Journal of Zhengzhou University，2017，38(1)：41-45.
• [25]陶文铨.数值传热学[M].西安：西安交通大学出版社，2001.TAO W Q.Numerical heat transfer[M].Xi'an：Xi'an Jiaotong University Press，2001.
• [26]王永庆，董其伍，刘敏珊.混沌对流强化传热的场协同分析[J].郑州大学学报，2011，32(3)：6-9.WANG Y Q，DONG Q W，LIU M S.Analysis of field synergy on heat transfer enhancement in chaotic advection[J].Journal of Zhengzhou University，2011，32(3)：6-9.
• [27]刘伟，刘志春，过增元.对流换热层流流场的物理量协同与传热强化分析[J].科学通报，2009，54(12)：1779-1785.LIU W，LIU Z C，GUO Z Y.Physical quantity synergy in laminar flow field of convective heat transfer and analysis of heat transfer enhancement[J].Chinese Science Bulletin，2009，54(12)：1779-1785.
• [28]冷学礼，张冠敏，田茂诚，等.场协同原理在对流换热中的应用方法[J].热能动力工程，2009，24(3)：352-354.LENG X L，ZHANG G M，TIAN M C，et al.Methods for applying field synergy principle in convection heat exchange[J].Journal of Engineering for Thermal Energy and Power，2009，24(3)：352-354.
• [29]何雅玲，雷勇刚，田丽亭，等.高效低阻强化换热技术的三场协同性探讨[J].工程热物理学报，2009，30(11)：1904-1906.HE Y L，LEI Y G，TIAN L T，et al.An analysis of three-field synergy on heat transfer augmentation with low penalty of pressure drop[J].Journal of Engineering Thermophysics，2009，30(11)：1904-1906.