刘业凤,陈申,周国梁
LIU Ye-feng,CHEN Shen,ZHOU Guo-liang

• 1:上海理工大学

摘要(Abstract)：

研制了一种采用斯特林型脉管制冷机为冷源,氦气为工质,有效容积为28 L,满足储存温度为-80℃的低温冰箱。该冰箱的制冷机采用直线电机驱动,冷指与箱体底部直接连接。长方体型箱体采用真空隔热板、聚氨酯发泡、气凝胶三层隔热材料复合保温技术。该低温冰箱在稳定运行下输入功率160 W、运行频率52 Hz时,制冷量为30 W,箱体内空气平均温度达到-93℃,箱体内空气平均降温速率为4.75℃/h,满足试验样品的低温储存需求,并提出相关的改进建议,为以后低温冰箱的设计提供参考。
An-80 ℃ low temperature refrigerator with stirling-type pulse tube cooler was developed. Its refrigerant is helium and the effective cubage is 28 L.The stirling cooler is driven by a linear motor, the cold-finger is installed at the bottom of refrigerator for directly cooling. Compound thermal insulation is adopted in the cuboid cabinet, the inner layer is vacuum insulation panel, the interlayer is aerogel and the outer layer is rigid polyurethane foam. Internal temperature of the refrigerator can be below-93 ℃ with the input power of 180 W and frequency of 52 Hz,and the output cooling capacity is 30 W during stable running, the average rate of temperature fall is 5 ℃/h,the refrigerator meet requirement of long term storage for laboratory sample, suggestions for improvement were proposed then.

关键词(KeyWords)： 脉管低温制冷机;电冰箱;斯特林循环;制冷性能试验
pulse tube cryogenic cryocooler;refrigerator;stirling cycle;refrigeration performance test

Abstract:

Keywords:

基金项目(Foundation): 上海市浦江人才计划资助项目(17PJ1407200)

作者(Author): 刘业凤,陈申,周国梁
LIU Ye-feng,CHEN Shen,ZHOU Guo-liang

参考文献(References)：

• [1]CHEN Xi,WU Weidong,ZHANG Hua,et al.A study of performance characteristics of a 40W&200K free piston stirling cooler[C].International Conference on Cryogenics&Refrigeration,April 5-9,2008,167.
• [2]陈曦,吴亦农,王维杨.斯特林制冷机用于冰箱技术的发展优势[J].制冷学报,2004,25(4):49-53.
• [3]陈国邦,颜鹏达,李金寿.斯特林低温制冷机的研究与发展[J].低温工程,2006,153(5):1-10.
• [4]陈曦,张华,吴亦农.200K/40W自由活塞斯特林制冷机的实验研究[J].上海理工大学学报,2007,29(4):337-340.
• [5]陈曦,张华,吴亦农.斯特林制冷机用于商业制冷的研究现状初析[J].制冷学报,2008,29(6):51-56.
• [6]王铁军,张文君,杨海明.便携式斯特林深冷冰箱研制[J].制冷学报,2011,32(2):27-29.
• [7]凌长明,陶文铨.冰箱内非稳态自然对流的二维数值模拟[J].西安交通大学学报,1995,29(10):35-41.
• [8]傅烈虎,丛伟,李青东.冰箱内温度场与流场数值模拟[J].制冷,2008,27(1):75-80.
• [9]Radebaugh R.Development of pulse tube refrigerators as an efficient and reliable cryocooler[J].Proceedings of Instituteof Refrigeration,2000,30(5):11-29.
• [10]赵韩,叶斌.家用冰箱与低温箱箱体设计的对比研究[J].低温特气,2003,21(4):10-12.
• [11]Rika Matsumoto.Investigation of the high,stable electricalconductivity in graphite intercalation compounds prepared fromflexible graphite sheets[J].Synthetic Metals,2014,198(8):107-112.
• [12]Guo xiangin,Wang Yanhui,Liu Xiaoxu,et al.Preparation of self-supporting graphene on flexible graphite sheet and electrodeposition of polyaniline for supercapacitor[J].Electrochimica Acta,2015,167(7):254-261.
• [13]Chi Yungwen,Yu Shenglin,Chen Henglu,et al.Thermal management of a proton exchange membrane fuel cel stack withpyrolyti graphite sheets and fanscombined[J].International Journal of Hydrogen Energy,2011,36(10):6082-6089.
• [14]候甜甜,轩福贞,项延训.非线性超声技术表征金属和有机材料塑性损伤的对比试验研究[J].压力容器,2016,33(3):9-15.
• [15]王俊强,何仁洋.含缺陷管道复合材料修复后承压能力研究[J].压力容器,2015,32(9)59-65.
• [16]王洪锐,许光,廖传军.低温复合材料气瓶爆破压力的有限元分析与试验研究[J].压力容器,2016,33(3):39-44.
• [17]戴玮,张锁龙,徐清华.铝制双波纹板束传热与流动的数值模拟和试验研究[J].压力容器,2017,34(1):7-152.
• [18]周世浩,谭跃刚,张帆,等.基于半导体制冷的巧克力3D打印成型条件研究[J].机电工程,2017,34(4):351-356.
• [19]Becker S,Vershinin S,Sartre V,et al.Steady state operation of a copper-water LHP with a flat-oval evaporator[J].Applied Thermal Engineering,2011,31(5):686-695.