污水源热泵系统的冷水与中介水温差的优化研究Study on Optimization of Temperature Difference of Cooling Water and That of Intermediate Water in Sewage Source Heat Pump
张敏,胡平放,罗新梅,雷飞,朱娜,邢路
ZHANG Min,HU Ping-fang,LUO Xin-mei,LEI Fei,ZHU Na,XING Lu
摘要(Abstract)：
空调系统的负荷侧与源侧的进出水设计温差是5℃,然而,从节能的角度看,传统的5℃温差并非对于所有的系统都是使得系统运行费用及初投资最低的最经济温差。本文通过对某间接式污水源热泵机组在非标况下的试验研究,对末端机组、污水-中介水换热器及水泵的运行分析,得出系统两端的最经济的温差,使得系统运行费用与初投资最低。
The designed temperature difference between inlet water and outlet water of the load side and source side in an air conditioning system is 5℃.However,from the point of energy saving,the traditional 5℃ is not most economical temperature difference to all the systems,making the lowest operating cost and initial cost.The paper obtains the most economical temperature difference between the sides of the system by conducting experimental researches under non-standard conditions and analyzing the operation of the FCU,heat exchanger and water pump,making the lowest operating cost and initial cost.
关键词(KeyWords)：
温差;风机盘管;换热器;水泵;热泵机组
temperature difference;FCU;heat exchanger;water pump;heat pump
基金项目(Foundation): 湖北省科技支撑计划项目(2014BAA137);; 华中科技大学研究生创新创业基金(0118650042)
作者(Author):
张敏,胡平放,罗新梅,雷飞,朱娜,邢路
ZHANG Min,HU Ping-fang,LUO Xin-mei,LEI Fei,ZHU Na,XING Lu
参考文献(References)：
- [1]吴荣华,孙德兴,张承虎,等.城市污水源热泵的应用与研究现[J].哈尔滨工业大学学报,2006,38(8):1326-1329.
- [2]吴荣华,刘志斌,黄磊,等.污水及地表水地源热泵系统规范化设计研究[J].暖通空调,2006,36(12):63-69.
- [3]丁兴风.空调冷水大温差对风机盘管性能的影响[D].上海:同济大学,2006.
- [4]韩伟国,陆亚俊.风机盘管加新风系统ε值比较设计方法研究[J].暖通空调,2001,32(5):80-83.
- [5]吴荣华,张承虎,孙德兴.城市原生污水冷热源黏度特性实验测试[J].哈尔滨工业大学学报,2006,38(9):1492-1495.
- [6]吴荣华,林福军.城市原生污水冷热源应用的关键因素研究[J].哈尔滨商业大学学报,2004,20(6):701-705.
- [7]庄兆意.直接式原生污水源热泵系统的防堵塞技术及换热特性研究[D].哈尔滨:哈尔滨工业大学,2012.
- [8]孙德兴,肖红侠,庄兆意,等.污水换热器的设计计算[J].暖通空调,2009,39(5):101-103.
- [9]陈永东,张贤安.煤化工大型缠绕管式换热器的设计与制造[J].压力容器,2015,32(1):36-44.
- [10]赵景玉,黄英,赵石军.煤化工大型缠绕管式换热器的设计与制造[J].压力容器,2015,32(3):36-44.
- [11]姚国梁.空调变频水泵节能问题探讨[J].暖通空调,2004,34(6):32-34.