排粉风机内部气固两相流动特性研究Research on Characteristic of Particle-gas Two-phase Flow inside the Coal-powder Exhauster
李建锋;吕俊复;张海;刘青;岳光溪;
LI Jian-feng1,LV Jun-fu2,ZHANG Hai2,LIU Qing2,YUE Guang-xi2(1.Scientific and Technical Service Center,China Electricity Council,Beijing 100038,China;2.Tsinghua University,Beijing 100084,China)
摘要(Abstract):
采用通用计算流体力学软件Fluent对某9-26型风机内部气固两相流进行了三维数值模拟,模拟结果显示了风机出口固相浓度的不均匀性,与实验测量结果一致。数值模拟表明,风机本身的离心力以及蜗壳内气流的夹带作用,导致固体颗粒向风机蜗壳的外侧面、后侧面聚集,该现象可以用于改善风机出口的颗粒分离。
The particle-gas two-phase flow in the high-pressure centrifugal blower of 9-26type was simulated three dimensionally with computational fluid dynamics Fluent.The result of the simulation showed the inhomogeneity of particle concentration at outlet of the exhauster,which agrees well with the measurement results. Particles enrichment near the outside and rear side of the volute casing is caused by the centrifugal force and the flow entrainment according to the simulation prediction.This phenomena could be used to improve the particles separation at the outlet of fan.
关键词(KeyWords):
气固两相流;离心风机;数值模拟;计算流体力学
particle-gas two-phase flow;centrifugal blower;numerical simulation;CFD
基金项目(Foundation): 国家重点基础研究发展规划项目(20026309)
作者(Authors):
李建锋;吕俊复;张海;刘青;岳光溪;
LI Jian-feng1,LV Jun-fu2,ZHANG Hai2,LIU Qing2,YUE Guang-xi2(1.Scientific and Technical Service Center,China Electricity Council,Beijing 100038,China;2.Tsinghua University,Beijing 100084,China)
参考文献(References):
- [1]Smoot L D,Hill S C,Xu H.NOx Control through re-burning[A].Progress in Energy and Combustion onScience[C].1998.385-408.
- [2]Chen W Y.Ma Long.Effect of heterogeneous mecha-nism during reburning of nitrogen oxide[J].AICHEJournal,1996,42(7):1968-1925.
- [3]徐璋,李戈,潘维,等.利用三次风细粉再燃降低NOx排放的几个关键问题分析[J].热力发电,2003(9):42-46.
- [4]郭宏伟,葛仕福.离心除尘风机的试验研究[J].流体机械,2002,30(3):4-5.
- [5]潘海波,郭宏伟,虞维平.离心除尘风机气固两相流动的数值模拟[J].流体机械,2005,33(6):11-13.
- [6]林建忠,林江,李玉麟,等.耐磨气固两相流离心风机的理论研究与开发[J].中国机械工程,2003,14(1):12-15.
- [7]游振江,林建忠,邵雪明.气固两相流风机磨损问题的研究综述[J].风机技术,2000,(1):14-18.
- [8]周建华.离心通风机叶片上粉尘的脱离[J].风机技术,2001,(3):6-8.
- [9]游斌,E E Elhadi,谢军龙,等.多翼离心风机的三维数值分析[J].工程热物理学报,2003,24(3):419-422.
- [10]陆蓓蕾,陈瑞球,石富金.离心风机的三维数值计算[J].煤矿机械,2005,(4):23-24.
- [11]伍晓芳,区颖达.空调用多翼离心风机叶轮的性能预估[J].华中科技大学学报(自然科学版),2003,31(10):69-71.
- [12]从静华,常思勤.便携式风力灭火机风机内部气流分析[J].南京林业大学学报(自然科学版),2003,27(6):55-58.
- [13]Tsan-Hsing Shih,William W.Liou,Aamir Shabbir,et al.A New k-εEddy Viscosity Model for HighReynolds Number Turbulent Flows[J].ComputersFluids,1995,24(3):227-238.
- [14]李建锋,吕俊复.风机流场的数值模拟[J].流体机械,2006,(4):10-13.
- [15]崔晓钰,翁建华,陈善年.离心通风机内气固两相流动计算[J].风机技术,2001,(4):44-47.
- 李建锋
- 吕俊复
- 张海
- 刘青
- 岳光溪
LI Jian-feng1- LV Jun-fu2
- ZHANG Hai2
- LIU Qing2
- YUE Guang-xi2(1.Scientific and Technical Service Center
- China Electricity Council
- Beijing 100038
- China
- 2.Tsinghua University
- Beijing 100084
- China)
- 李建锋
- 吕俊复
- 张海
- 刘青
- 岳光溪
LI Jian-feng1- LV Jun-fu2
- ZHANG Hai2
- LIU Qing2
- YUE Guang-xi2(1.Scientific and Technical Service Center
- China Electricity Council
- Beijing 100038
- China
- 2.Tsinghua University
- Beijing 100084
- China)