流体机械

2016, v.44;No.525(03) 65-69+37

[打印本页] [关闭]
本期目录(Current Issue) | 过刊浏览(Past Issue) | 高级检索(Advanced Search)

润滑油对R32在水平光管内流动沸腾换热特性及压降的影响
Impact of Lubricating Oil on Heat Transfer and Pressure Drop Characteristics of R32 Boiling in Horizontal Tube

李炅;张秀平;贾磊;谢文海;罗小鹏;
LI Jiong;ZHANG Xiu-ping;JIA Lei;XIE Wen-hai;LUO Xiao-peng;Hefei General Machinery Research Institute;

摘要(Abstract):

对R32在φ5mm和φ7mm的水平光管内的流动沸腾时,润滑油对换热与压降特性的影响进行了试验研究,试验的质量流量范围为100~500 kg/(m~2·s),润滑油的含量在0~5%之间。结果表明,沸腾换热系数随着质量流量的增大而增大。在低干度区,换热系数随干度的增大而增大,当干度达到0.7~0.8时,换热系数达到最大。随着润滑油含量的增大,局部换热系数在减小。压降随着管径的减小和质量流量的增大而增大。润滑油含量的增大,导致压降的增大。在5mm管内,润滑油含量对换热系数和压降影响比较明显。
Impact of lubricating oil on heat transfer and pressure drop characteristics of R32 boiling in φ5mm and φ7mm horizontal tube was studied by experiment. Range of mass flow was 100 ~ 500 kg /(m~2·s),and content of lubricating oil was from 0 to 5%. The results showed that heat transfer coefficient increased with mass flow increasing. Heat transfer coefficient increased with the dryness increasing at low zone. When the dryness reached 0.8,heat transfer started to deteriorate due to the influence of lubricating oil.Heat transfer coefficient decreased with lubricating oil increased. The pressure drop reduced with the flow rate and the pipe diameter increasing. As content of lubricating oil increased,the pressure drop also increased. In φ5mm tube,affect of the lubricating oil was relatively obvious for heat transfer coefficient and pressure drop.

关键词(KeyWords): R32;润滑油;沸腾;换热系数
R32;lubricating oil;boiling;heat transfer coefficient

Abstract:

Keywords:

基金项目(Foundation): 国家质量监督检验检疫总局:质检公益性行业科研专项基金项目(201410047)

作者(Author): 李炅;张秀平;贾磊;谢文海;罗小鹏;
LI Jiong;ZHANG Xiu-ping;JIA Lei;XIE Wen-hai;LUO Xiao-peng;Hefei General Machinery Research Institute;

Email:

DOI:

参考文献(References):

扩展功能
本文信息
服务与反馈
本文关键词相关文章
本文作者相关文章
中国知网
分享