R32在带闪蒸器的风冷冷热水机组中的应用研究Application Study of Air Cooled Chiller with a Flash Tank Using R32
尹茜,周威
YIN Qian,ZHOU Wei
摘要(Abstract)：
从理论方面分析了R32在制热尤其是低温制热方面的优势,同时指出低温制热下R32系统受到排气温度过高的限制。作者提出采用闪蒸器的方法降低排气温度,将R32和R410A分别应用在带闪蒸器的风冷冷热水机组中进行试验研究。试验结果表明,压缩机排量相当的情况下,R32机组名义工况下能力及性能系数均略有提高,且名义制热工况下提高幅度更高,R32在制热方面更有优势;环境温度越低,R32机组制热量提高幅度越大,R32在低温制热方面更有优势,而且R32的排气温度可以控制在可以接受的范围内。
The advantage of R32 in heating conditions especially in low air temperature heating conditions was theoretically analyzed. This application was limited because of higher discharge temperature of R32. it was suggested that discharge temperature was controlled with a flash tank. Comparative test was conducted in air cooled chiller with a flash tank using R32 and R410 A respectively. The results indicate that with the almost same compressor discharge volume,the capacity and COP in nominal conditions of R32 unit is higher than R410 A unit,the increase is much more in nominal heating condition,R32 unit takes advantage in heating conditions; when the air temperature is lower,the capacity increase of R32 unit is much more,R32 unit takes advantage in low air temperature heating conditions,the discharge temperature can also be controlled with a flash tank.
关键词(KeyWords)：
R32;风冷冷热水机组;闪蒸器
R32;air cooled chiller;flash tank
基金项目(Foundation):
作者(Author):
尹茜,周威
YIN Qian,ZHOU Wei
参考文献(References)：
- [1]史敏,贾磊,钟瑜,等.R32用于单元式空调机的性能实验研究[J].制冷与空调,2011,11(2):78-80.
- [2]王朝鑫,朱兴旺,龚毅.R32灌注式替代R410A家用空调的试验研究[J].流体机械,2011,39(7):65-67.
- [3]林小茁,赵薰,江辉民.R32替代R22的可行性探讨[J].制冷与空调,2011,11(2):73-77.
- [4]梅奎,李明,梁路军.R32和R410A循环特性对比研究[J].制冷与空调,2011,11(2):56-59.
- [5]熊建国,唐道轲,周胡根.R32制冷剂在风冷冷热水机组上替代R410A的实验研究[J].制冷空调与电力机械,2011,32(3):13-15.
- [6]矢岛龙三郎,吉见敦史,朴春成.降低R32压缩机排气温度的方法[J].制冷与空调,2011,11(2):60-64.
- [7]秦妍,张剑飞.R32制冷系统降低排气温度的方法研究[J].制冷学报,2012,33(1):14-17.
- [8]张倩,晏刚,白涛.一种新型R32两级压缩热泵空调器的理论研究[J].制冷技术,2011,39(2):30-36.
- [9]许树学.带经济补气的R32制冷/热泵系统实验研究[J].土木建筑与环境工程,2011,33(2):98-102.
- [10]Xu Xing,Hwang Yunho,Reinhard Radermacher.Performance Comparison of R410A and R32 in Vapor Injection Cycles[J].International Journal of Refrigeration,2013,36(3):892-903.
- [11]于文远,李征涛,陈阿勇,等.R32在带经济器的风冷冷热水机组的试验研究[J].流体机械,2014,42(7):65-68.
- [12]张新玉,郭宪民,张森林.R32中间补气压缩空气源热泵系统的试验研究[J].流体机械,2015,43(5):61-64.
- [13]王定标,谷帆江,向飒,等.螺旋内助扭曲管换热与流阻性能研究[J].压力容器,2016,33(2):25-29.
- [14]何理,张焰.R32风冷冷(热)水机组低温制热性能探讨[J].制冷与空调,2014,14(10):52-54.