曹健,苏林,张辛辛,孙寒晴,李康,方奕栋
CAO Jian,SU Lin,ZHANG Xinxin,SUN Hanqing,LI Kang,FANG Yidong

• 1:上海理工大学能源与动力工程学院

摘要(Abstract)：

为了研究小压比、短型线的两对腔(N=2)涡旋压缩机的补气性能,采用第二制冷剂量热器法搭建了测量补气式涡旋压缩机的性能试验台,在不同热泵工况及补气压力下进行了试验研究与分析。结果显示:基于试验工况,有补气相对于无补气均可使涡旋压缩机的排气温度降低;压缩机制热量随补气压力的升高而增加,而制热COP(能效比)则随补气压力的增大先上升后下降,4个工况下峰值处的COP较无补气时分别增大了11.45%,7.28%,2.09%,3.56%;低温热泵名义制热工况下涡旋压缩机的容积效率随着补气压力的提高而逐渐增大,热泵名义制热工况下(工况3、工况4)补气压力对容积效率影响甚微,分别维持在0.55及0.50附近;所测工况下的压缩机效率随补气压力的增加先增大后减小。
In order to study the vapor injection performance of the scroll compressor with two-pair-chamber(N=2) with small pressure ratio and short profile，the second calorimeter method was used to build a test bench for measuring the performance of the scroll compressor with vapor injection and experimental research and analysis were carried out under different heat pump conditions and injection pressure.The experimental results indicate that discharge temperature of the scroll compressor with or without vapor injection can be reduced.The heating capacity of the compressor under the measured conditions increases with the increase of the injection pressure，while the heating COP(Heating Coefficient of Performance) first rises and then decreases with the increase of the injection pressure.The heating COP at peak value under 4 operating conditions was increased by 11.45%，7.28%，2.09% and 3.56%，respectively，compared with non-vapor injection.The volumetric efficiency of scroll compressor increases with the increase of injection pressure under nominal heating condition of low temperature heat pump.The vapor injection pressure has little effect on the volumetric efficiency，the values remain around 0.55 and 0.50，respectively，under nominal heating condition of heat pump(Operating Condition 3，Operating Condition 4).The compressor efficiency first increases and then decreases with the increase of injection pressure under the measured conditions.

关键词(KeyWords)： 热泵空调;两对腔涡旋压缩机;喷气增焓(EVI);补气压力
heat pump air conditioner;two-pair-chamber scroll compressor;enhanced vapor injection(EVI);injection pressure

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金项目（51876130,51906158）

作者(Author): 曹健,苏林,张辛辛,孙寒晴,李康,方奕栋
CAO Jian,SU Lin,ZHANG Xinxin,SUN Hanqing,LI Kang,FANG Yidong

参考文献(References)：

• [1]张磊，贺春辉，张威，等.应用R410A制冷剂的补气增焓热泵型电动汽车空调的制热性能实验研究[J].暖通空调，2019，49(6)：131-134.ZHANG L，HE C H，ZHANG W，et al.Heating performance experiment of electric vehicle air conditioner with supplying air and increasing enthalpy for cooling and R410A as refrigerant[J].Heating Ventilating & Air Conditioning，2019，49(6)：131-134.
• [2]刘强，樊水冲，何珊.喷气增焓涡旋压缩机在空气源热泵热水器中的应用[J].流体机械，2008，36(9)：68-72.LIU Q，FAN S C，HE S.Application of enhanced vapor injection technology in ASHPWH[J].Fluid Machinery，2008，36(9)：68-72.
• [3]ZHANG D，LI J，NAN J，et al.Thermal performance prediction and analysis on the economized vapor injection air-source heat pump in cold climate region of China[J].Sustainable Energy Technologies and Assessments，2016，18：127-133.
• [4]崔嵩.补气式涡旋压缩机特性研究[D].长春：吉林大学，2019.CUI S.Research on characteristic of gas-injection scroll compressor[D].Changchun：Jilin University，2019.
• [5]谭希.5 kW准二级压缩热泵系统的特性与试验研究[D].武汉：华中科技大学，2012.TAN X.Theoretical and experimental study on a 5 kW quasi-two stage compression heat pumping system[D].Wuhan：Huazhong University of Science and Technology，2012.
• [6]柴玉鹏，马国远，许树学，等.带闪蒸器补气的R134a准二级压缩制冷/热泵系统实验研究[J].制冷学报，2017，38(2)：11-16.CHAI Y P，MA G Y，XU S X，et al.Experimental research on quasi two-stage compression heat pump with flash tank vapor-injection using R134a[J].Journal of Refrigeration，2017，38(2)：11-16.
• [7]CHO I Y，SEO H J，KIM D，et al.Performance comparison between R410A and R32 multi-heat pumps with a sub-cooler vapor injection in the heating and cooling modes[J].Energy，2016，112：179-187.
• [8]SHI Y，GUO X，ZHANG X.Study on economized vapor injection heat pump system using refrigerant R32[J].International Journal of Air-Conditioning and Refrigeration，2016，24(1)：1650006.
• [9]WANG X，HWANG Y，RADERMACHER R.Two-stage heat pump system with vapor-injected scroll compressor using R410A as a refrigerant[J].International Journal of Refrigeration，2009，32(6)：1442-1451.
• [10]KIM D，JEON Y，JANG D S，et al.Performance comparison among two-phase，liquid，and vapor injection heat pumps with a scroll compressor using R410A[J].Applied Thermal Engineering，2018，137：193-202.
• [11]QIN F，XUE Q，ALBARRACIN VELEZ G M，et al.Experimental investigation on heating performance of heat pump for electric vehicles at-20℃ambient temperature[J].Energy Conversion and Management，2015，102：39-49.
• [12]冉小鹏，翟晓强，骆琼.喷气增焓空气源热泵补气量对系统性能的影响[J].制冷学报，2019，40(4)：37-44.RAN X P，ZHAI X Q，LUO Q.Effect of Vapor-injection mass on system performance air-source heat pump with enhanced vapor injection[J].Journal of Refrigeration，2019，40(4)：37-44.
• [13]张新玉，郭宪民，张森林.R32中间补气压缩空气源热泵系统的试验研究[J].流体机械，2015，43(5)：61-64.ZHANG X Y，GUO X M，ZHANG S L.Experimental Study on performance of economized vapor injection heat pump system using refrigerant R32[J].Fluid Machinery，2015，43(5)：61-64.
• [14]XU X，HWANG Y，RADERMACHER R.Performance comparison of R410A and R32 in vapor injection cycles[J].International Journal of Refrigeration，2013，36(3)：892-903.
• [15]CHO I Y，KO S B，KIM Y.Optimization of injection holes in symmetric and asymmetric scroll compressors with vapor injection[J].International Journal of Refrigeration，2012，35(4)：850-860.
• [16]孙寒晴，苏林，张辛辛，等.电动空调涡旋压缩机型线优化[J].轻工机械，2020，38(2)：84-89.SUN H Q，SU L，ZHANG X X，et al.Optimization analysis of scroll compressor profile for electric air conditioning[J].Light Industry Machinery，2020，38(2)：84-89.
• [17]国家市场监督管理总局，中国国家标准化管理委员会.汽车空调用电动压缩机总成：GB/T 22068—2018[S].北京：中国标准出版社，2018.State Administration for Market Regulation，Standardization Administration of People’s Republic of China.Electrically driven compressor assembly for automobile air conditioning：GB/T 22068—2018[S].Beijing：Standards Press of China，2018.