宁静红,孙庆烨
NING Jinghong,SUN Qingye

• 1:天津商业大学天津市制冷技术重点实验室

摘要(Abstract)：

对以R290为工质的闪发器中间补气的高温热泵系统进行性能分析,得出:随补气前压力比增大,R290闪发器高温热泵系统的平衡补气压力增大,相对补气量减小,压缩机总功耗减小,系统制热量减小,压缩机排气温度升高。系统存在最佳补气前压力比,使系统获得最优的性能系数。蒸发温度为30 ℃、冷凝温度为85 ℃时,补气前压力比为1.5时获得最大性能系数3.61。随蒸发温度增加,平衡补气压力增加,相对补气量减小,压缩机总功耗增加,制热量增加,系统性能系数减小。随冷凝温度升高,相应平衡补气压力升高,相对补气量增大,压缩机总功耗减小,制热量减小,系统性能系数增加。在最佳补气前压力比为1.5工况下,与常规高温热泵系统比较,性能系数提高18.57%,压缩机排气温度下降10.03 ℃。研究结果为进一步开发R290为工质的闪发器中间补气的高温热泵系统提供理论基础。
The performance analysis of vapor-injected high temperature heat pump system with the flash tank using R290 as the working fluid shows that as the pressure ratio before vapor injection increases，the balanced vapor injection pressure of the R290 high temperature heat pump systems with flash tank increases，and the relative vapor injection volume decreases，the total power consumption of the compressor decreases，the system heating capacity decreases，and the compressor exhaust temperature increases.The system has an optimum pressure ratio before vapor injection，so that the system can obtain the best performance coefficient.When the evaporation temperature is 30 ℃，the condensation temperature is 85 ℃ and the optimum pressure ratio beforevapor injection is 1.5，the maximum coefficient of performance is 3.61.With the increase of evaporation temperature，the equilibrium vapor injection pressure increases，the relative vapor injection volume decreases，the total power consumption of the compressor increases，the heating capacity increases，and the system performance coefficient decreases.With the increase of condensation temperature，the corresponding balanced vapor injection pressure increases，the relative vapor injection volume increases，the total power consumption of the compressor decreases，the heating capacity decreases，and the system performance coefficient increases.Compared with the conventional high temperature heat pump system under the working conditions with the optimal pressure ratio of 1.5 before vapor injection，the coefficient of performance is increased by 18.57%，and the compressor exhaust temperature is reduced by 10.03 ℃.The research results provide a theoretical basis for further developing the vapor-injected high temperature R290 heat pump system with the flash tank.

关键词(KeyWords)： 中间补气;闪发器;高温热泵;热力性能
vapor-injected;flash tank;high temperature heat pump;thermal performance

Abstract:

Keywords:

基金项目(Foundation): 天津市自然科学基金项目（18JCYBJC22200）

作者(Author): 宁静红,孙庆烨
NING Jinghong,SUN Qingye

参考文献(References)：

• [1]吴迪，胡斌，王如竹，等.我国空气源热泵供热现状、技术及政策[J].制冷技术，2017，37(5)：1-7.WU D，HU B，WANG R Z，et al.Present situation，technology and policy of air source heat pump heating in china[J].Chinese Journal of Refrigeration Technology，2017，37(5)：1-7.
• [2]BAEK C，HEO J，JUNG J，et al.Effects of vapor injection techniques on the heating performance of a CO2 heat pump at low ambient temperatures[J].International Journal of Refrigeration，2014，43(7)：26-35.
• [3]JIANG S，WANG S G，JIN X，et al.Optimum compressor cylinder volume ratio for two-stage compression air source heat pump systems[J].International Journal of Refrigeration，2016，67：77-89.
• [4]MA G Y，LI X G.Exergetic optimization of a key design parameter in heat pump systems with economizer coupled with scroll compressor[J].Energy Conversion & Management，2007，48(4)：1150-1159.
• [5]赵会霞，马国远.涡旋压缩机闪发器系统性能的模拟分析[J].流体机械，2006，34(9)：15-20.ZHAO H X，MA G Y.Performance simulation on economizer system coupled with scroll compressor[J].Fluid Machinery，2006(9)：15-20.
• [6]孙浩然，胡海涛，李浩，等.带闪发器的中间补气型热泵系统稳态仿真模型[J].化工学报，2018，69(S2)：260-265.Sun H R，Hu H T，Li H，et al.Steady-state simulation model of vapor-injected heat pump systems with flash tank[J].Journal of Chemical Industry，2018，69(S2)：260-265.
• [7]ZHANG S J，WANG H X，GUO T.Experimental investigation of moderately high temperature water source heat pump with non-azeotropic refrigerant mixtures[J].Applied Energy，2010，87(5)：1554-1561.
• [8]李亚伦，李保国，朱传辉.太阳能热泵干燥技术研究进展[J].包装与食品机械，2018，36(6)：53-58.LI Y L，LI B G，ZHU C H.Application and developments on solar assisted heat pump drying technology[J].Packaging and Food Machinery，2018，36(6)：53-58.
• [9]JIANG S，WANG S，JIN X，et al.A general model for two-stage vapor compression heat pump systems[J].International Journal of Refrigeration，2015，51：88-102.
• [10]陈云，舒水明，丁国忠，等.高温混合工质空气源热泵性能试验研究[J].流体机械，2013，41(12)：1-5.CHEN Y，SHU S M，DING G Z，et al.Experimental study on the performance of high temperature air source heat pump with refrigerant mixture[J].Fluid Machinery，2013，41(12)：1-5.
• [11]潘利生，王怀信.带经济器的两级压缩式热泵系统中高温工况循环性能理论研究[J].太阳能学报，2012，33(11)：1908-1913.PAN L S，WANG H X.Theoreical study on two-stage compression heat pump with economizer in moderately high temperature situation[J].Acta Energiae Solaris Sinica，2012，33(11)：1908-1913.
• [12]KIM D，CHUNG H J，JEON Y，et al.Optimization of the injection-port geometries of a vapor injection scroll compressor based on SCOP under various climatic conditions[J].Energy，2017，135：442-454.
• [13]宁静红，诸凯，刘圣春.R404A直接接触凝结制冷循环的性能分析[J].低温工程，2017(3)：38-42.NING J H，ZHU K，LIU S C.Analysis on the performance of R404A direct contact consedation refrigeration cycle[J].Cryogenics，2017(3)：38-42.
• [14]谭希，舒水明，丁国忠，等.带中间补气涡旋式压缩机的热泵循环性能研究[J].制冷与空调，2010(10)：21-25.TAN X，SHU S M，DING G Z，et al.Cycle performance study on heat pump system with scroll compressor with intermediate gas supply[J].Refrigeration and Air Conditioning，2010(10)：21-25.
• [15]秦黄辉.带闪蒸型经济器的风冷螺杆热泵机组性能的实验研究[J].制冷学报，2013，34(5)：55-58.QIN H S.Experimental study on performance of air-cooled screw heat pump with flash tank economizer[J].Journal of Refrigeration，2013，34(5)：55-58.